 |
|
Dried distiller's grains can help produce more beef
January 05, 2007AMARILLO - Supplemental feeding of dried distiller's grains to cattle can help produce more beef in grazing programs, a Texas Agricultural Experiment Station researcher said.
After a summer and fall feeding study done with both heifers and steers, Dr. Jim MacDonald, Experiment Station beef nutritionist, said he believes this by-product of ethanol production will be useful in more than just feedlot or dairy operations.
In the next few years, an additional 200 to 600 million gallons of ethanol are expected to be produced in the High Plains, MacDonald said. Production will utilize up to 214 million bushels of corn or sorghum and result in 1.71 million tons of distiller's grains.
"A majority will likely be utilized by feedyards and dairies, but due to the sheer increase in availability, there should be opportunities for cow/calf and stocker operations to use it as well," he said.
The most promising opportunity may be in the situation where lightweight calves are held for a couple of months before they go onto wheat, MacDonald said.
The summer grazing study using heifers averaging 600 pounds compared feeding 3 pounds of dried distiller's grain per head per day, or approximately 0.5 percent of the animal's body weight, to no supplement, MacDonald said.
Results showed an improvement in gain of a quarter of a pound per head per day over the control calves, he said.
In the fall dormant range study, steers weighing approximately 400 pounds were compared at unsupplemented, 1-pound, 2-pound and 3-pound per head per day rates, MacDonald said.
Gain improved from just over one-half pound per head per day at the 1-pound rate to 1.75 pound per head per day at the highest level of supplementation, he said.
"However, the effect was quadratic in that the more you supplemented, the incremental gain was lower," MacDonald said. "In other words, at the 1-pound rate, the efficiency of gain was about 50 percent, where at the highest rate, it was 40 percent."
During the summer trial, the efficiency was only about 10 percent, he said, because both sets of animals were eating well on grass and the supplementation did not make as big a difference..
"So supplementation is more efficient on dormant range, as you would expect," MacDonald said.
The economics of supplementing with distiller's grains will depend on the cost of the product compared to the value of gain, he said.
MacDonald paid $118 per ton for the distiller's grains, which equated to a $12.50 per head investment for $18.80 per head in return over the 63 days the heifers were fed.
As corn prices have risen over the past month or so, so has that of distiller's grain, he said. The same scenario now would have the producer paying $175 per ton, which would result in a $18.96 per head investment for a $16.20 per head return.
"Producers need to run the economics in their situation to see if it is a good fit," he said.
The 56-day fall trial, using the $175 per ton rate for the distiller's grains, resulted in at $16.33 per head investment at the highest level of supplementation, MacDonald said. That investment was worth $68.25 per head.
"The economics would say in the fall or winter scenario, producers will want to supplement at as high levels as possible," he said.
"And even though this research is conducted with stocker calves, I think there is opportunity for cow/calf producers to utilize the distiller's grains as well," MacDonald said. "The supplemental fat has shown to improve reproduction, as well as providing energy to maintain or improve body condition score."
However, potential dangers exist if animals are fed at extreme rates due to fat and sulfur content, he said. Excessive fat can reduce forage digestibility. Also, sulfur can tie up minerals such as copper, creating a deficiency. Excessive sulfur may cause polioencephalomalacia, also known as "brainers."
Producers who use distiller's grains need to be cognizant of all sulfur sources, including water, MacDonald said. If a producer is feeding distiller's grains high in sulfur and also have sulfur in their water, it could be enough to cause trouble.
The supplementation trials were only the first step in MacDonald's study, he said.
Comparisons of distiller's grains to more traditional supplementation and following the calves onto wheat pasture need to done, he said.
"I'm very much enthused about using distiller's grains to produce more beef on a fixed-land base," he said. "The caveat will be to see what previous supplementation does to subsequent wheat grazing gains. We'll have some data on that in the spring."
Texas A&M University - Agricultural Communications
"A majority will likely be utilized by feedyards and dairies, but due to the sheer increase in availability, there should be opportunities for cow/calf and stocker operations to use it as well," he said.
The most promising opportunity may be in the situation where lightweight calves are held for a couple of months before they go onto wheat, MacDonald said.
The summer grazing study using heifers averaging 600 pounds compared feeding 3 pounds of dried distiller's grain per head per day, or approximately 0.5 percent of the animal's body weight, to no supplement, MacDonald said.
Results showed an improvement in gain of a quarter of a pound per head per day over the control calves, he said.
In the fall dormant range study, steers weighing approximately 400 pounds were compared at unsupplemented, 1-pound, 2-pound and 3-pound per head per day rates, MacDonald said.
Gain improved from just over one-half pound per head per day at the 1-pound rate to 1.75 pound per head per day at the highest level of supplementation, he said.
"However, the effect was quadratic in that the more you supplemented, the incremental gain was lower," MacDonald said. "In other words, at the 1-pound rate, the efficiency of gain was about 50 percent, where at the highest rate, it was 40 percent."
During the summer trial, the efficiency was only about 10 percent, he said, because both sets of animals were eating well on grass and the supplementation did not make as big a difference..
"So supplementation is more efficient on dormant range, as you would expect," MacDonald said.
The economics of supplementing with distiller's grains will depend on the cost of the product compared to the value of gain, he said.
MacDonald paid $118 per ton for the distiller's grains, which equated to a $12.50 per head investment for $18.80 per head in return over the 63 days the heifers were fed.
As corn prices have risen over the past month or so, so has that of distiller's grain, he said. The same scenario now would have the producer paying $175 per ton, which would result in a $18.96 per head investment for a $16.20 per head return.
"Producers need to run the economics in their situation to see if it is a good fit," he said.
The 56-day fall trial, using the $175 per ton rate for the distiller's grains, resulted in at $16.33 per head investment at the highest level of supplementation, MacDonald said. That investment was worth $68.25 per head.
"The economics would say in the fall or winter scenario, producers will want to supplement at as high levels as possible," he said.
"And even though this research is conducted with stocker calves, I think there is opportunity for cow/calf producers to utilize the distiller's grains as well," MacDonald said. "The supplemental fat has shown to improve reproduction, as well as providing energy to maintain or improve body condition score."
However, potential dangers exist if animals are fed at extreme rates due to fat and sulfur content, he said. Excessive fat can reduce forage digestibility. Also, sulfur can tie up minerals such as copper, creating a deficiency. Excessive sulfur may cause polioencephalomalacia, also known as "brainers."
Producers who use distiller's grains need to be cognizant of all sulfur sources, including water, MacDonald said. If a producer is feeding distiller's grains high in sulfur and also have sulfur in their water, it could be enough to cause trouble.
The supplementation trials were only the first step in MacDonald's study, he said.
Comparisons of distiller's grains to more traditional supplementation and following the calves onto wheat pasture need to done, he said.
"I'm very much enthused about using distiller's grains to produce more beef on a fixed-land base," he said. "The caveat will be to see what previous supplementation does to subsequent wheat grazing gains. We'll have some data on that in the spring."
Texas A&M University - Agricultural Communications
Beef Current Events and Beef News RSSChanges in urine could lead to BSE test for live animals
Researchers have demonstrated that protein levels in urine samples can indicate both the presence and progress of Bovine Spongiform Encephalopathy (BSE) disease in cattle.
Iowa State University experts can discuss new FDA produce irradiation rule
The Food and Drug Administration's new (Aug. 22) regulation that will allow irradiation pasteurization to be used on fresh spinach and iceberg lettuce to kill illness-causing bacteria is a step that two Iowa State University professors have long advocated.
New mushroom study shows the power of energy density
Preliminary research, led by Dr. Lawrence Cheskin, MD, Director of John Hopkins Weight Management Center, suggests increasing intake of low-energy density foods, specifically mushrooms, in place of high-energy-density foods, like lean ground beef, is a strategy for preventing or treating obesity.
Actions of individuals key to saving biodiversity-and ourselves, Stanford biologists say
Even if you don't like the outdoors, you're probably pretty fond of air, clean water and food. That makes you a fan of biodiversity, because those essentials for life-human and otherwise-are maintained as a direct result of the Earth's biodiversity, the abundance and variety of species and populations on the planet. Preserving a substantial amount of biodiversity is critical to a healthy future for us, but how best to do that has been a subject of ongoing debate.
Pathogen that causes disease in cattle also associated with Crohn's disease
People with Crohn's disease (CD) are seven-fold more likely to have in their gut tissues the bacterium that causes a digestive-tract disease in cattle called Johne's disease.
Study predicts crop-production costs will jump dramatically in 2009
Soaring energy prices will yield sharp increases for corn and soybean production next year, cutting into farmers' profits and stretching already high food costs, according to a new University of Illinois study.
Even before tomato warning, many Americans lacked confidence in the food safety system
A new national study conducted by the Harvard School of Public Health Project on the Public and Biological Security finds that, in spite of a number of food safety incidents in recent years, most Americans remain confident that the food produced in the United States is safe. However, many have concerns about the safety of imported food produced in some other countries.
Feedstock makes a difference in feeding distiller's grains
When it comes to using distiller's grains in finishing rations of High Plains cattle, a Texas AgriLife Research scientist says the type of grain used makes all the difference.
New cell-based sensors sniff out danger like bloodhounds
A small, unmanned vehicle makes its way down the road ahead of a military convoy. Suddenly it stops and relays a warning to the convoy commander. The presence of a deadly improvised explosive device, or IED, has been detected by sophisticated new sensor technology incorporating living olfactory cells on microchips mounted on the unmanned vehicle. The IED is safely dismantled and lives are saved.
Costs, considerations of switching to natural or organic methods
When Kansas State University graduate student Ben Wileman was a practicing veterinarian in Belle Fourche, S.D., natural and organic labels were a big focus for the beef producers he saw.
More Beef Current Events and Beef News Articles
 | Storey's Guide to Raising Beef Cattle: Health/Handling/Breeding by Heather Smith Thomas A bovine expert, Thomas explains facilities, breeding and genetics, calving, health care, and advice for marketing a cattle... |
 | Salad Bar Beef by Joel Salatin |
| The Ultimate Ground Beef Cookbook by Taste of Home | |
 | Beef: The Untold Story of How Milk, Meat, and Muscle Shaped the World by Andrew Rimas, Evan Fraser The cow. The most industrious animal in the world. A beast central to human existence since time began, it has played a vital role in our history not only as a source of food, but also as a means of labor, an economic resource, an inspiration for art, and even as a religious icon. Prehistoric people painted it on cave walls; explorers, merchants, and landowners traded it as currency; many... |
 | The Healthy Beef Cookbook: Steaks, Salads, Stir-fry, and More - Over 130 Luscious Lean Beef Recipes for Every Occasion by American Dietetic Association (ADA), National Cattleman's Beef Association, Richard Chamberlain, Betsy Hornick More than 130 healthy beef recipes from the top authority in nutrition Lean beef can be a key part of a healthy diet. Calorie for calorie, it's one of nature's most nutrient-rich foods. Now, the National Cattlemen's Beef Association and the American Dietetic Association show today's health-conscious cooks exciting new ways to use lean beef in everything from quick and easy mid-week suppers... |
 | Beef Production Management and Decisions (5th Edition) by Tom G. Field, Robert E. Taylor Based on the most recent scientific, demographic and financial data available, "Beef Production and Management Decisions, Fifth Edition" examines the biological, ecological, financial, and marketing issues impacting the beef industry today. Harnessing the authors' industry and academic experience, the book explores the demographics, structure, challenges and segments of the industry from a... |
 | Raising a Calf for Beef (A Garden Way Publishing Book) by Phyllis Hobson This no-nonsense how-to guide for beginners offers detailed information on choosing a calf, building and maintaining housing, nutrition, feeding, and daily care. Readers will also find instructions for slaughtering and butchering. 120,000 copies in... |
 | Beyond Beef: The Rise and Fall of the Cattle Culture (Plume) by Jeremy Rifkin An analysis of the beef culture incorporates anthropology, history, sociology, economics, and ecology to demonstrate how ""cattle culture"" has changed our world. Reprint. 25,000 first printing. National... |
 | Jerky: Make Your Own Delicious Jerky and Jerky Dishes Using Beef, Venison, Fish, or Fowl by A. D. Livingston A guide to making the popular high-protein, low-fat dried meat snack.... |
 | Getting Started with Beef & Dairy Cattle (Getting Started With) by Heather Smith Thomas With nearly every supermarket now featuring an “organic” section, the demand for organically grown meat and dairy products has risen rapidly in recent years. Small farmers have taken note, and many more beginners are considering cattle as a viable farm commodity. Getting Started with Beef & Dairy Cattle is the essential handbook for this growing audience. Heather Smith Thomas, a lifelong... |
| © 2008 BrightSurf.com |