 |
|
NIST chemists get scoop on crude 'oil' from pig manure
June 13, 2008After a close examination of crude oil made from pig manure, chemists at the National Institute of Standards and Technology (NIST) are certain about a number of things.
Most obviously, "This stuff smells worse than manure," says NIST chemist Tom Bruno.
But a job's a job, so the NIST team has developed the first detailed chemical analysis revealing what processing is needed to transform pig manure crude oil into fuel for vehicles or heating. Mass production of this type of biofuel could help consume a waste product overflowing at U.S. farms, and possibly enable cutbacks in the nation's petroleum use and imports. But, according to a new NIST paper,* pig manure crude will require a lot of refining.
The ersatz oil used in the NIST analyses was provided by engineer Yuanhui Zhang of the University of Illinois Urbana-Champaign. Zhang developed a system using heat and pressure to transform organic compounds such as manure into oil.
As described in the new paper, Bruno and colleagues determined that the pig manure crude contains at least 83 major compounds, including many components that would need to be removed, such as about 15 percent water by volume, sulfur that otherwise could end up as pollution in vehicle exhaust, and lots of char waste containing heavy metals, including iron, zinc, silver, cobalt, chromium, lanthanum, scandium, tungsten and minute amounts of gold and hafnium. Whatever the pigs eat, from dirt to nutritional supplements, ends up in the oil.
While the thick black liquid may look like its petroleum-based counterparts, the NIST study shows that looks can be deceiving. "The fact that pig manure crude oil contains a lot of water is unfavorable. They would need to get the water out," Bruno says.
The measurements were made with a new NIST test method and apparatus, the advanced distillation curve, which provides highly detailed and accurate data on the makeup and performance of complex fluids. A distillation curve charts the percentage of the total mixture that evaporates as a sample is slowly heated. Because the different components of a complex mixture typically have different boiling points, a distillation curve gives a good measure of the relative amount of each component in the mixture. NIST chemists enhanced the traditional technique by improving precision and control of temperature measurements and adding the capability to analyze the chemical composition of each boiling fraction using a variety of advanced methods.
NIST researchers analyzed the graphite-like char remaining after the distillation by bombarding it with neutrons, a non-destructive way of identifying the types and amounts of elements present. Two complementary neutron methods detected the heavy metals listed above.
Bruno and colleagues currently spend much of their time analyzing military jet fuels and are not planning a major foray into pig manure. But Bruno concedes that the effort may have a payoff. "Who knows, it might help decrease the nuisance of manure piles."
National Institute of Standards and Technology (NIST)
The ersatz oil used in the NIST analyses was provided by engineer Yuanhui Zhang of the University of Illinois Urbana-Champaign. Zhang developed a system using heat and pressure to transform organic compounds such as manure into oil.
As described in the new paper, Bruno and colleagues determined that the pig manure crude contains at least 83 major compounds, including many components that would need to be removed, such as about 15 percent water by volume, sulfur that otherwise could end up as pollution in vehicle exhaust, and lots of char waste containing heavy metals, including iron, zinc, silver, cobalt, chromium, lanthanum, scandium, tungsten and minute amounts of gold and hafnium. Whatever the pigs eat, from dirt to nutritional supplements, ends up in the oil.
While the thick black liquid may look like its petroleum-based counterparts, the NIST study shows that looks can be deceiving. "The fact that pig manure crude oil contains a lot of water is unfavorable. They would need to get the water out," Bruno says.
The measurements were made with a new NIST test method and apparatus, the advanced distillation curve, which provides highly detailed and accurate data on the makeup and performance of complex fluids. A distillation curve charts the percentage of the total mixture that evaporates as a sample is slowly heated. Because the different components of a complex mixture typically have different boiling points, a distillation curve gives a good measure of the relative amount of each component in the mixture. NIST chemists enhanced the traditional technique by improving precision and control of temperature measurements and adding the capability to analyze the chemical composition of each boiling fraction using a variety of advanced methods.
NIST researchers analyzed the graphite-like char remaining after the distillation by bombarding it with neutrons, a non-destructive way of identifying the types and amounts of elements present. Two complementary neutron methods detected the heavy metals listed above.
Bruno and colleagues currently spend much of their time analyzing military jet fuels and are not planning a major foray into pig manure. But Bruno concedes that the effort may have a payoff. "Who knows, it might help decrease the nuisance of manure piles."
National Institute of Standards and Technology (NIST)
Manure News and Current Manure Events RSSDrinking water in Gaza Strip contaminated with high levels of nitrate
Palestinian and German scientists have recommended to the authorities in the Gaza Strip that they take immediate measures to combat excessive nitrate levels in the drinking water.
Why eating less can help the environment
An estimated 19 percent of total energy used in the USA is taken up in the production and supply of food. Currently, this mostly comes from non-renewable energy sources which are in short supply.
Cow power could generate electricity for millions
Converting livestock manure into a domestic renewable fuel source could generate enough electricity to meet up to three per cent of North America's entire consumption needs and lead to a significant reduction in greenhouse gas emissions (GHGs), according to US research published today.
Improving Swine Waste Fertilizer
Swine production generates large amounts of waste. While this waste contains nutrients that may serve as fertilizer when applied to agricultural fields, the ratio of nutrients in the waste is different than what a crop requires.
Keeping yields, profits and water quality high
One of the key questions facing agriculturalists in the 21st century is how to produce adequate amounts of food and farm income while protecting environmental quality.
Biogas production is all in the mixing
Engineers at Washington University in St. Louis, using an impressive array of imaging and tracking technologies, have determined the importance of mixing in anaerobic digesters for bioenergy production and animal and farm waste treatment.
Fueling Ethanol Production While Protecting Water Quality
Grain-based ethanol production has increased dramatically in recent years as the cost and instability of oil has increased. New U.S. government policies require major increases in ethanol production. While future plans call for a viable cellulosic ethanol industry, expanded grain ethanol production will lead to further growth of corn acres in the near term, with unintended negative water quality impacts.
Compost can turn agricultural soils into a carbon sink, thus protecting against climate change
Applying organic fertilizers, such as those resulting from composting, to agricultural land could increase the amount of carbon stored in these soils and contribute significantly to the reduction of greenhouse gas emissions.
Detecting synthetic fertilizers: Is it organic or not?
As organic farming becomes more common, methods to identify fraud in the industry are increasingly important. In a recent study in Journal of Environmental Quality, scientists successfully use nitrogen isotopic discrimination to determine if non-organic, synthetic fertilizers were used on sweet pepper plants.
Life at the jolt
Researchers at the Biodesign Institute are using the tiniest organisms on the planet 'bacteria' as a viable option to make electricity. In a new study featured in the journal Biotechnology and Bioengineering, lead author Andrew Kato Marcus and colleagues Cesar Torres and Bruce Rittmann have gained critical insights that may lead to commercialization of a promising microbial fuel cell (MFC) technology.
More Manure News Articles
 | If Democrats Had Any Brains, They'd Be Republicans by Ann Coulter “Uttering lines that send liberals into paroxysms of rage, otherwise known as ‘citing facts,’ is the spice of life. When I see the hot spittle flying from their mouths and the veins bulging and pulsing above their eyes, well, that’s when I feel truly alive.”So begins If Democrats Had Any Brains, They’d Be Republicans, Ann Coulter’s funniest, most... |
 | The Humanure Handbook: A Guide to Composting Human Manure, Third Edition by Joseph C. Jenkins There are almost seven billion defecating people on planet Earth, but few who have any clue about how to constructively handle the burgeoning mountain of human crap. The Humanure Handbook, third edition, will amuse you, educate you, and possibly offend you, but it will certainly pertain to you—unless, of course, your bowels never move.This new edition of The Humanure Handbook is:The Tenth... |
 | Soil Fertility and Fertilizers: An Introduction to Nutrient Management (6th Edition) by John L. Havlin, Samuel L. Tisdale, Werner L. Nelson, James D. Beaton Long regarded as the leading book in the field, this volume provides a basic introduction to the biological, chemical, and physical properties affecting soil fertility and plant nutrition. It covers all aspects of nutrient management for profitable crop production, with particular attention to minimizing the environmental impact of soil and fertilizer management. The Sixth Edition has been... |
 | Growing Media for Ornamental Plants and Turf by Kevin Handreck, Neil Black For nearly twenty years, Growing Media for Ornamental Plants and Turf has been established as a core text for students of horticulture and an essential reference for practicing horticulturalists and their suppliers, landscape gardeners and designers, and greenkeepers. This third edition, substantially revised from the last edition published in 1994, has been expanded by 70 pages and contains 48... |
 | Godless: The Church of Liberalism by Ann Coulter "If a martian landed in America and set out to determine the nation's official state religion, he would have to conclude it is liberalism, while Christianity and Judaism are prohibited by law.Many Americans are outraged by liberal hostility to traditional religion. But as Ann Coulter reveals in this, her most explosive book yet, to focus solely on the Left's attacks on our Judeo-Christian... |
 | New York's Poop Scoop Law: Dogs, the Dirt, and Due Process by Michael Brandow It's hard to imagine eight million people trying to avoid dog refuse on the streets of New York City on a daily basis. It's harder not to imagine New Yorkers from all walks of life picking up after their canines. Using plastic bags or trendy, mechanized devices, pet owners have become a unified force in cleaning up the sidewalks of the Big Apple. We forget that Health Law 1310, which went into... |
 | How to Shovel Manure and Other Life Lessons for the Country Woman by Gwen Petersen It’s not a job you want to take on without a sense of humor. Oops--it’s not a job at all. It’s an all-encompassing life, being a country woman on the ranch or farm, and with wit and equanimity like Gwen Petersen’s, it can be survived. In fact, with Petersen’s help, it can be drop-dead hilarious. A much-loved cowgirl scribe in rare form, Petersen eases us through the... |
 | Return to Manure by Raymond Federman In 1942, after hiding to escape the Nazis, our narrator (named, simply, Federman) finds his way to Vichy France. Unwanted by his relatives, he is forced to spend the remainder of the war as an unpaid laborer. For three wordless years on the farm, this thirteen-year-old is assailed by suffering, death, sex, and the back-breaking labor of shoveling manure. Sixty years later, in the United... |
 | Money, Manure & Maintenance: Ingredients for Successful Gardens of Marian Coffin Pioneer Landscape Architect 1876-1957 by Nancy Fleming Money, Manure, and Maintenance were the three ingredients necessary for successful gardens, according to Marian Coffin, a pioneer landscape architect in the first half of the 20th century. The book contains many illustrations of Coffin's garden designs, including Delaware estates: Winterthur, Mt. Cuba, and Gibraltar, as well as the King's Garden at Ft. Ticonderoga, and other estate gardens and... |
 | Soil Fertility Management for Sustainable Agriculture by James F. Power, Rajendra Prasad This book addresses the key to the development of sustainable agriculture management of soil fertility. Combining data from temperate and tropical regions, it presents a complete picture of how various soils can best be managed under widely different environmental conditions. This book serves as an excellent reference for professionals as well as a textbook for undergraduate and graduate students... |
| © 2008 BrightSurf.com |