 |
|
Scrubbing sulfur
August 18, 2009RICHLAND, Wash. - The Department of Energy's Pacific Northwest National Laboratory has developed a reusable organic liquid that can pull harmful gases such as carbon dioxide or sulfur dioxide out of industrial emissions from power plants. The process could directly replace current methods and allow power plants to capture double the amount of harmful gases in a way that uses no water, less energy and saves money.
"Power plants could easily retrofit to use our process as a direct replacement for existing technology," said David Heldebrant, PNNL's lead research scientist for the project.
Harmful gases such as carbon dioxide or sulfur dioxide are called "acid gases". The new scrubbing process uses acid gas-binding organic liquids that contain no water and appear similar to oily compounds. These liquids capture the acid gases near room temperature. Scientists then heat the liquid to recover and dispose of the acid gases properly.
These recyclable liquids require much less energy to heat but can hold two times more harmful gases by weight than the current leading liquid absorbent used in power plants. It is a combination of water and monoethanolamine, a basic organic molecule that grabs the carbon dioxide.
PNNL's previous work with the all-organic liquids focused on pulling only carbon dioxide out of emissions from power plants. New work will show how the process can be applied to other acid gases such as sulfur dioxide.
"Current methods used to capture and release carbon dioxide emissions from power plants use a lot of energy because they pump and heat an excess of water during the process," said Heldebrant. He notes the monoethanolamine component is too corrosive to be used without the excess water.
In PNNL's process called "Reversible Acid Gas Capture," the molecules that grab onto the acid gases are already in liquid form, and don't contain water. The acid gas-binding organic liquids require less heat than water does to release the captured gases.
Heldebrant and colleagues demonstrated the process in previous work with a carbon dioxide-binding organic liquid, called CO2BOL. In this process, scientists mix the CO2BOL solution into a holding tank with emissions that contain carbon dioxide. The CO2BOL chemically binds with the carbon dioxide to form a liquid salt solution.
In another tank, scientists reheat the salt solution to strip out the carbon dioxide. Non-hazardous gases such as nitrogen would not be captured and are released back into the atmosphere. The toxic compounds are captured separately for storage. At that point, the CO2BOL solution is back in its original state and ready for reuse.
Heldebrant and colleagues have developed organic liquid systems that bind three additional acid gases found in emissions. He will talk about new work with sulfur dioxide, carbonyl sulfide, and carbon disulfide -- all acid gases that are environmentally harmful -- at the American Chemical Society Fall 2009 Meeting and Exposition, Tuesday, August 18, at 4:30 p.m. EDT.
DOE/Pacific Northwest National Laboratory
These recyclable liquids require much less energy to heat but can hold two times more harmful gases by weight than the current leading liquid absorbent used in power plants. It is a combination of water and monoethanolamine, a basic organic molecule that grabs the carbon dioxide.
PNNL's previous work with the all-organic liquids focused on pulling only carbon dioxide out of emissions from power plants. New work will show how the process can be applied to other acid gases such as sulfur dioxide.
"Current methods used to capture and release carbon dioxide emissions from power plants use a lot of energy because they pump and heat an excess of water during the process," said Heldebrant. He notes the monoethanolamine component is too corrosive to be used without the excess water.
In PNNL's process called "Reversible Acid Gas Capture," the molecules that grab onto the acid gases are already in liquid form, and don't contain water. The acid gas-binding organic liquids require less heat than water does to release the captured gases.
Heldebrant and colleagues demonstrated the process in previous work with a carbon dioxide-binding organic liquid, called CO2BOL. In this process, scientists mix the CO2BOL solution into a holding tank with emissions that contain carbon dioxide. The CO2BOL chemically binds with the carbon dioxide to form a liquid salt solution.
In another tank, scientists reheat the salt solution to strip out the carbon dioxide. Non-hazardous gases such as nitrogen would not be captured and are released back into the atmosphere. The toxic compounds are captured separately for storage. At that point, the CO2BOL solution is back in its original state and ready for reuse.
Heldebrant and colleagues have developed organic liquid systems that bind three additional acid gases found in emissions. He will talk about new work with sulfur dioxide, carbonyl sulfide, and carbon disulfide -- all acid gases that are environmentally harmful -- at the American Chemical Society Fall 2009 Meeting and Exposition, Tuesday, August 18, at 4:30 p.m. EDT.
DOE/Pacific Northwest National Laboratory
Carbon Dioxide Current Events and Carbon Dioxide News RSSScripps research scientists find new link between insulin and core body temperature
A team led by scientists at The Scripps Research Institute have discovered a direct link between insulin-a hormone long associated with metabolism and metabolic disorders such as diabetes-and core body temperature.
Oceans' uptake of manmade carbon may be slowing
The oceans play a key role in regulating climate, absorbing more than a quarter of the carbon dioxide that humans put into the air.
Developing 'green' tires that boost mileage and cut carbon dioxide emissions
A new generation of "green" automobile tires that can boost fuel efficiency without sacrificing safety and durability is rolling their way through the research pipeline.
Berkeley Lab Lends Expertise to India to Promote Energy Efficiency
ndia may rank only a distant fourth in terms of carbon dioxide emissions, behind China, the United States and Russia, but its rapid economic growth rate coupled with aging and inefficient energy infrastructure suggest dire environmental consequences if "business as usual" continues.
Tiny bubbles clean oil from water
Small amounts of oil leave a fluorescent sheen on polluted water. Oil sheen is hard to remove, even when the water is aerated with ozone or filtered through sand.
Health care accounts for 8 percent of US carbon footprint
The American health care sector accounts for nearly a tenth of the country's carbon dioxide emissions, according to a first-of-its-kind calculation of health care's carbon footprint.
Climate studies to benefit from 12 years of satellite aerosol data
Aerosols, very small particles suspended in the air, play an important role in the global climate balance and in regulating climate change.
Controversial new climate change results
New data show that the balance between the airborne and the absorbed fraction of carbon dioxide has stayed approximately constant since 1850, despite emissions of carbon dioxide having risen from about 2 billion tons a year in 1850 to 35 billion tons a year now.
Newly Discovered Fat Molecule: An Undersea Killer with an Upside
A chemical culprit responsible for the rapid, mysterious death of phytoplankton in the North Atlantic Ocean has been found by collaborating scientists at Rutgers University and the Woods Hole Oceanographic Institution (WHOI). This same chemical may hold unexpected promise in cancer research.
DNA barcodes: Creative new uses span health, fraud, smuggling, history, more
The scientific ability to quickly and accurately identify species through DNA "barcoding" is being embraced and applied by a growing legion of global authorities - from medical and agricultural researchers to police and customs authorities to palaeontologists and others.
More Carbon Dioxide Current Events and Carbon Dioxide News Articles
 |
The Carbon Dioxide Syndrome by Jennifer Stark and Russell Stark (Author) Learn why changing your breathing can improve your health and well-being through the Butekyo Method. This method will help those with sleep disorders, panic attacks, allergies, hypertension and asthma. |
 |
First Alert CO400 Battery Powered Carbon Monoxide Alarm by First Alert Carbon monoxide (CO) is the leading cause of accidental poisoning deaths in America, yet many people don't know they are suffering from CO poisoning until its too late. Since symptoms of CO poisoning are like the flu, you might not even know you're in danger at first. That's why a carbon monoxide alarm is an excellent way to protect your family. It can detect the CO you can't see, smell or taste in the air. The First Alert CO400 carbon monoxide alarm uses an electrochemical carbon monoxide sensor-the most accurate technology available. The permanent sensor lasts up to five years. It is powered by two AA replaceable alkaline batteries giving you peace of mind even during power outages. The test/silence button both silences the alarm and allows you to test its functionality. The unit... |
 |
Carbon Dioxide and the Climate Crisis: Reality or Illusion? Also With: CO2Science (Producer) Al Gore calls the host of negative consequences he predicts will accompany the on-going rise in the air's CO2 concentration "a planetary emergency - a crisis that threatens the survival of our civilization and the habitability of the earth." James Hansen similarly claims that the earth "is close to dangerous climate change, to tipping points of the system with the potential for irreversible deleterious effects," and he contends that "ignoring the climate problem at this time, for even another decade, would serve to lock in future catastrophic climatic change." Do these dire contentions reflect reality? Or do they portray but a marvelously-crafted and hugely-effective illusion? Carbon Dioxide and the Climate Crisis: Reality or Illusion? explores this perplexing problem through an... |
 |
Carbon Dioxide (CO2) Cylinder 10 Lbs This cylinder is able to hold 10 lbs of CO2. It is constructed of light weight aluminum with matte aluminum finish. CO2 Cylinders are shipped empty. Be sure to see the other draft beer products sold by Learn To Brew LLC. |
 |
First Alert Smoke and Carbon Monoxide Alarm - SC01CN3 by First Alert First Alert SCO1CN3 smoke and carbon monoxide detector uses ionization method of smoke detection. It features a test button and a silence button that temporarily quiets both the carbon monoxide and smoke alarms. When battery is low, the warning "chirp" and light flashes. The alarm makes different horn sounds and light flash patterns for carbon monoxide and smoke. |
 |
Fire Extinguisher Carbon Dioxide 5 Lb. by Global Industrial KIDDE CARBON DIOXIDE EXTINGUISHER Effective for Class B and C fires. Environmentally safe, Co2 gas dissipates quickly leaving no residue and won't contaminate food, valuable materials or electronics. Seamless aluminum cylinder has a durable epoxy paint finish. Long-lasting nickelchrome plated brass valve with stainless steel handle and lever. Includes a heavy-duty wall hanger. 5 year warranty. Non-Returnable. 5 pounds UL Rating: 5B:C |
 |
Kidde 900-0107 Plug-In Carbon Monoxide Alarm by Kidde Safety 110V Non-Digital AC Carbon Monoxide Alarm With Direct Plug Alarm Only 85 Decibel Alarm Test Reset Button To Reset Alarm Advanced Electrochemical Sensor 5 Year Warranty UL Listed To 2,034 Standard Clam Shell |
|
Carbon Dioxide Incubator Accessories for Isotemp/Thermo Scientific NAPCO Models; Roller Base by Thermo Scientific Forma Roller Base, Incubator Accessory; For Isotemp DH and NAPCO 8000 Series DH CO2 Incubators; with locking casters and leveling feet | |
 |
^CarboLime Carbon Dioxide Absorbent - Pre-packaged cartridge, 2.5 lb (1.13 kg) Min.Order is 1 CS ( 12 Each / Case; ) by Medline CarboLime is a granular solar lime absorbent for the efficient removal of carbon dioxide from closed and semi-closed patient breathing circuits. Contains no potassium hydroxide. Minimum dust levels with the benefits of high surface area and graded particle size. Low bulk density. Low risk of carbon monoxide formation due to good reisistance of dry gas desiccation. Low odor due to reliable control of indicator dye concenntration. Carb-O-Lime Absorbent Granules Efficiently Remove Carbon Dioxide 12 Each / Case; |
|
Carbon Dioxide Maoi (Primary Contributor) |
| © 2009 BrightSurf.com |