Nav: Home

Research could lead to more durable cell phones and power lines

January 03, 2019

BINGHAMTON, N.Y. - Researchers from Binghamton University, State University of New York have developed a way to make cell phones and power lines more durable. 

Binghamton University Assistant Professor of Mechanical Engineering Sherry Towfighian and graduate student Mark Pallay created a new type of microelectromechanical system - more commonly known as a MEMS switch - that uses electrostatic levitation to provide a more robust system. 

"All cell phones use MEMS switches for wireless communication, but traditionally there are just two electrodes," said Towfighian. "Those switches open and close numerous times during just one hour, but their current lifespan is limited by the two-electrode system."

When the two electrodes come into contact - after several repetitions - the surface of the bottom electrode becomes damaged, leading to a MEMS switch that has to be discarded and replaced. Some researchers have tried to avoid the damage by adding dimples or landing pads to the electrodes to reduce the contact area when the electrodes collide, but Towfighian explained that this only delays the eventual breakdown of the material.

She wanted to create a system that avoids the damage altogether. Instead of following the two-electrode model, she designed a MEMS switch with three electrodes on the bottom and one electrode parallel to the others. The two bottom electrodes on the right and left side are charged while the middle and top electrodes are grounded.

"This type of MEMS switch is normally closed, but the side electrodes provide a strong upward force that can overcome the forces between the two middle electrodes and open the switch," explained Towfighian. This force, called electrostatic levitation, is currently not available with the two-electrode system. The ability to generate this force prevents permanent damage of the device after continuous use and enables a reliable bi-directional switch.

"For cell phones, this design means longer life and fewer component replacements," said Towfighian. "For power lines, this type of MEMS switch would be useful when voltage goes beyond a limit and we want to open the switch. The design allows us to have more reliable switches to monitor unusual spikes in voltage, like those caused by an earthquake, that can cause danger to public safety."
-end-
The study, titled "A reliable MEMS switch using electrostatic levitation," was published in Applied Physics Letters. This research was funded by the National Science Foundation's Division of Electrical, Communications and Cyber Systems (ECCS) grant #1608692.

Binghamton University

Related Cell Phones Articles:

Dissemination of pathogenic bacteria by university student's cell phones
New research has demonstrated the presence of S. aureus in 40% of the cell phones of students sampled at a university.
'Technoference': We're more tired & less productive because of our phones
An Australian survey of 709 mobile phone users (aged 18 to 83), led by Queensland University of Technology, has found one in five women and one in eight men are losing sleep due to bad phone habits.
Research could lead to more durable cell phones and power lines
Researchers from Binghamton University, State University of New York have developed a way to make cell phones and power lines more durable. 
Cell phones without annual plans offer limited help to homeless people
The vast majority of older homeless adults have access to mobile phones, but they are usually basic phones, without annual contracts that let them keep stable numbers, and thus are only practical for one-way communication, according to a UC San Francisco study of how homeless people use mobile and Internet technology.
Laws designed to ban or curb drivers' use of cell phones are saving motorcyclists' lives
Laws to ban or curb drivers' use of cell phones and other handheld devices have greatly reduced the rate of fatalities for motorcyclists, according to a new study from Florida Atlantic University and the University of Miami.
Toxic chemicals calling: Cell phones as a source of flame retardants
New research by environmental scientists at the University of Toronto suggests that the exterior of mobile phones could be a source of toxic chemicals, or at least an aggregate indicator of the chemicals to which people are exposed on a daily basis.
About half of parents use cell phones while driving with young children in the car
A new study from a team of researchers at Children's Hospital of Philadelphia and the University of Pennsylvania School of Nursing found that in the previous three months, about half of parents talked on a cell phone while driving when their children between the ages of 4 and 10 were in the car, while one in three read text messages and one in seven used social media.
Ultrasound-firewall for mobile phones
Mobile phones and tablets through so-called audio tracking, can be used by means of ultrasound to unnoticeably track the behaviour of their users: for example, viewing certain videos or staying in specific rooms and places.
Cell phones at summer camp: Research explores the effects
New research from University of Michigan C.S. Mott Children's Hospital delves into how digital media might affect the camp experience.
Spider silk could be used to power microphones in hearing aids, cell phones
Would you want a spider web inside your ear? Probably not.
More Cell Phones News and Cell Phones Current Events

Top Science Podcasts

We have hand picked the top science podcasts of 2019.
Now Playing: TED Radio Hour

Risk
Why do we revere risk-takers, even when their actions terrify us? Why are some better at taking risks than others? This hour, TED speakers explore the alluring, dangerous, and calculated sides of risk. Guests include professional rock climber Alex Honnold, economist Mariana Mazzucato, psychology researcher Kashfia Rahman, structural engineer and bridge designer Ian Firth, and risk intelligence expert Dylan Evans.
Now Playing: Science for the People

#541 Wayfinding
These days when we want to know where we are or how to get where we want to go, most of us will pull out a smart phone with a built-in GPS and map app. Some of us old timers might still use an old school paper map from time to time. But we didn't always used to lean so heavily on maps and technology, and in some remote places of the world some people still navigate and wayfind their way without the aid of these tools... and in some cases do better without them. This week, host Rachelle Saunders...
Now Playing: Radiolab

Dolly Parton's America: Neon Moss
Today on Radiolab, we're bringing you the fourth episode of Jad's special series, Dolly Parton's America. In this episode, Jad goes back up the mountain to visit Dolly's actual Tennessee mountain home, where she tells stories about her first trips out of the holler. Back on the mountaintop, standing under the rain by the Little Pigeon River, the trip triggers memories of Jad's first visit to his father's childhood home, and opens the gateway to dizzying stories of music and migration. Support Radiolab today at Radiolab.org/donate.