Nav: Home

Lettuce show you how to restore oil-soaked soil

February 01, 2019

Rice University engineers have figured out how soil contaminated by heavy oil can not only be cleaned but made fertile again.

How do they know it works? They grew lettuce.

Rice engineers Kyriacos Zygourakis and Pedro Alvarez and their colleagues have fine-tuned their method to remove petroleum contaminants from soil through the age-old process of pyrolysis. The technique gently heats soil while keeping oxygen out, which avoids the damage usually done to fertile soil when burning hydrocarbons cause temperature spikes.

While large-volume marine spills get most of the attention, 98 percent of oil spills occur on land, Alvarez points out, with more than 25,000 spills a year reported to the Environmental Protection Agency. That makes the need for cost-effective remediation clear, he said.

"We saw an opportunity to convert a liability, contaminated soil, into a commodity, fertile soil," Alvarez said.

The key to retaining fertility is to preserve the soil's essential clays, Zygourakis said. "Clays retain water, and if you raise the temperature too high, you basically destroy them," he said. "If you exceed 500 degrees Celsius (900 degrees Fahrenheit), dehydration is irreversible."

The researchers put soil samples from Hearne, Texas, contaminated in the lab with heavy crude, into a kiln to see what temperature best eliminated the most oil, and how long it took.

Their results showed heating samples in the rotating drum at 420 C (788 F) for 15 minutes eliminated 99.9 percent of total petroleum hydrocarbons (TPH) and 94.5 percent of polycyclic aromatic hydrocarbons (PAH), leaving the treated soils with roughly the same pollutant levels found in natural, uncontaminated soil.

The paper appears in the American Chemical Society journal Environmental Science and Technology. It follows several papers by the same group that detailed the mechanism by which pyrolysis removes contaminants and turns some of the unwanted hydrocarbons into char, while leaving behind soil almost as fertile as the original. "While heating soil to clean it isn't a new process," Zygourakis said, "we've proved we can do it quickly in a continuous reactor to remove TPH, and we've learned how to optimize the pyrolysis conditions to maximize contaminant removal while minimizing soil damage and loss of fertility.

"We also learned we can do it with less energy than other methods, and we have detoxified the soil so that we can safely put it back," he said.

Heating the soil to about 420 C represents the sweet spot for treatment, Zygourakis said. Heating it to 470 C (878 F) did a marginally better job in removing contaminants, but used more energy and, more importantly, decreased the soil's fertility to the degree that it could not be reused.

"Between 200 and 300 C (392-572 F), the light volatile compounds evaporate," he said. "When you get to 350 to 400 C (662-752 F), you start breaking first the heteroatom bonds, and then carbon-carbon and carbon-hydrogen bonds triggering a sequence of radical reactions that convert heavier hydrocarbons to stable, low-reactivity char."

The true test of the pilot program came when the researchers grew Simpson black-seeded lettuce, a variety for which petroleum is highly toxic, on the original clean soil, some contaminated soil and several pyrolyzed soils. While plants in the treated soils were a bit slower to start, they found that after 21 days, plants grown in pyrolyzed soil with fertilizer or simply water showed the same germination rates and had the same weight as those grown in clean soil.

"We knew we had a process that effectively cleans up oil-contaminated soil and restores its fertility," Zygourakis said. "But, had we truly detoxified the soil?"

To answer this final question, the Rice team turned to Bhagavatula Moorthy, a professor of neonatology at Baylor College of Medicine, who studies the effects of airborne contaminants on neonatal development. Moorthy and his lab found that extracts taken from oil-contaminated soils were toxic to human lung cells, while exposing the same cell lines to extracts from treated soils had no adverse effects. The study eased concerns that pyrolyzed soil could release airborne dust particles laced with highly toxic pollutants like PAHs.

''One important lesson we learned is that different treatment objectives for regulatory compliance, detoxification and soil-fertility restoration need not be mutually exclusive and can be simultaneously achieved," Alvarez said.
-end-
Wen Song, a visiting scholar at Rice and a student at the University of Jinan and Shandong University, China, is lead author of the paper. Co-authors are Rice alumna Julia Vidonish of Arcadis U.S., Seattle; Rice postdoctoral researcher Pingfeng Yu; Roopa Kamath, an environmental adviser at Chevron; Chun Chu, a research associate at Baylor College of Medicine; and Baoyu Gao, a professor of environmental engineering at Shandong University. Alvarez is the George R. Brown Professor of Materials Science and NanoEngineering and a professor of civil and environmental engineering at Rice. Zygourakis is the A.J. Hartsook Professor of Chemical and Biomolecular Engineering and a professor of bioengineering.

The research was supported by Chevron U.S.A., the National Natural Science Foundation of China, the Shanghai Tongji Gao Tingyao Environmental Science and Technology Development Foundation, the Taishan Scholar Program and the National Institutes of Health.

Read the abstract at https://pubs.acs.org/doi/10.1021/acs.est.8b05825.

This news release can be found online at https://news.rice.edu/2019/02/01/lettuce-show-you-how-to-restore-oil-soaked-soil/

Follow Rice News and Media Relations via Twitter @RiceUNews.

Related materials:

Alvarez Lab: http://alvarez.rice.edu/alvarez-lab/

Zygourakis Lab: http://ithaca.rice.edu

George R. Brown School of Engineering: https://engineering.rice.edu

Located on a 300-acre forested campus in Houston, Rice University is consistently ranked among the nation's top 20 universities by U.S. News & World Report. Rice has highly respected schools of Architecture, Business, Continuing Studies, Engineering, Humanities, Music, Natural Sciences and Social Sciences and is home to the Baker Institute for Public Policy. With 3,962 undergraduates and 3,027 graduate students, Rice's undergraduate student-to-faculty ratio is just under 6-to-1. Its residential college system builds close-knit communities and lifelong friendships, just one reason why Rice is ranked No. 1 for lots of race/class interaction and No. 2 for quality of life by the Princeton Review. Rice is also rated as a best value among private universities by Kiplinger's Personal Finance. To read "What they're saying about Rice," go to http://tinyurl.com/RiceUniversityoverview.

Rice University

Related Fertility Articles:

Fertility preservation for children with differences of sex development
Article explores unique ethical issues for children with differences of sex development on whether or not they should pursue fertility preservation.
In roundworms, fats tip the scales of fertility
Two University of Colorado Boulder scientists have discovered how fat levels in a tiny soil-dwelling roundworm (C. elegans) can tip the balance between whether the worm makes eggs or sperm.
Fertility can hinge on swimming conditions in the uterus
A Washington State University researcher has found that the uterus in female mice contains enzymes that can break down semen, making it less gel-like, more watery, and therefore easier to swim in.
Ladies, this is why fertility declines with age
Researchers at the University of Montreal Hospital Research Center (CRCHUM) have discovered a possible new explanation for female infertility.
Many transgender individuals consider their fertility important, survey shows
Nearly one-fourth of transgender individuals in Toronto, Canada, regard their own fertility as important, but most lack knowledge regarding and access to reproductive options, a new survey finds.
A rapid, automated and inexpensive fertility test for men
Scientists have developed a low-cost and easy-to-use smartphone attachment that can quickly and accurately evaluate semen samples for at-home fertility testing, providing a potentially helpful resource for the more than 45 million couples worldwide who are affected by infertility.
Cows may offer clues to improving fertility in women
A Michigan State University researcher has received a $1.65 million grant that looks to bring a better understanding about fertility treatments in women by studying the effect of hormones on ovulation and reproduction in cows.
Men have a lot to learn about their own fertility
The first large-scale study of its kind has revealed that Canadian men generally lack knowledge about the risk factors contributing to male infertility.
Spinning semen provides a measurement of fertility
The maths of collective behavior has provided a new technique for selecting the best semen for artificial insemination in livestock.
Control of fertility: A new player identified
Individual small RNAs are responsible for controlling the expression of gonadoliberin or GnRH (Gonadotropin-Releasing Hormone), a neurohormone that controls sexual maturation, the appearance of puberty, and fertility in adults.

Related Fertility Reading:

Best Science Podcasts 2019

We have hand picked the best science podcasts for 2019. Sit back and enjoy new science podcasts updated daily from your favorite science news services and scientists.
Now Playing: TED Radio Hour

Bias And Perception
How does bias distort our thinking, our listening, our beliefs... and even our search results? How can we fight it? This hour, TED speakers explore ideas about the unconscious biases that shape us. Guests include writer and broadcaster Yassmin Abdel-Magied, climatologist J. Marshall Shepherd, journalist Andreas Ekström, and experimental psychologist Tony Salvador.
Now Playing: Science for the People

#513 Dinosaur Tails
This week: dinosaurs! We're discussing dinosaur tails, bipedalism, paleontology public outreach, dinosaur MOOCs, and other neat dinosaur related things with Dr. Scott Persons from the University of Alberta, who is also the author of the book "Dinosaurs of the Alberta Badlands".