Application of potassium to grass used as cover crop guarantees higher-quality cotton

February 16, 2021

By Maria Fernanda Ziegler | Agência FAPESP – The use of cover crops between cotton harvests protects the soil, conserves water, and reduces the risk of erosion. Researchers at the University of Western São Paulo (UNOESTE) and São Paulo State University (UNESP) in Brazil found that application of potassium (K) to a grass cover crop grown before cotton in sandy soil lowered production cost and resulted in cotton with a higher market value.

“The dynamics of early application of potassium to grass planted as a cover crop before cotton results in more resistant fibers and a smaller proportion of short fibers than when the conventional method of applying the nutrient to the cotton crop is used. In addition to the improvement in quality, the technique reduces production cost for the farmer because of its impact on operational dynamics. The farmer can apply potassium once instead of twice. The technique saves labor and diesel oil, as well as optimizing operational logistics. In the long run, it’s also expected to reduce fertilizer use,” said Fábio Echer, a professor at UNOESTE and lead author of an article on the study published in Scientific Reports.

The two-year study, which was conducted on UNOESTE’s experimental farm, compared the conventional method of fertilizing cotton directly with two other methods, both involving early application of potassium. It also evaluated cotton growing without fertilizer and without a cover crop.

The research was funded by a master’s scholarship awarded by FAPESP to Vinicius José Souza Peres. The São Paulo State Cotton Growers Association (APPA) and Fundação Agrisus also collaborated on the project.

Quantitative and qualitative analysis of fiber

In one of the treatments, the researchers applied potassium to the grass cover crop in two doses (70 kg per hectare each). They compared this with application to the cover crop of a single dose of 140 kg per hectare and split application, with half going to the cover crop and the other half to the cotton. The results in terms of fiber yield were identical to those of the conventional method. Yield and quality were both lower with no fertilizer than when the conventional method or early application was used.

“The study included a calculation of fertilizer use efficiency,” Echer told Agência FAPESP. “We found that early application enabled the forage grass used as a cover crop to recover nutrients from the soil, in addition to the function of protecting it. This plant has a deep rhizosphere and its roots are able to find soil nutrients lost via leaching from previous crops, recycling them, and pushing them back to the surface. When the plant dries out, it releases potassium in the first rain to the crops that come next.”

The main advantage of early application, however, is that it increases the commercial value of the cotton produced. The analysis of fiber quality and cotton value found that fertilizing the cover crop with potassium led to a smaller proportion of short fibers, which depreciate the finished product, and also enhanced fiber fineness (micronaire), maturity and strength. “These characteristics are important. They represent higher commercial value for the production of finer cotton fabric, which is better quality and fetches a higher price on the market,” Echer said.

The improvement in quality relates to the availability of potassium in the soil and plant water status. “Cotton fiber is a cell, and like all cells it needs water to expand. By conserving more water in the soil and in the plant, we can also improve fiber size,” he explained.

Potassium plays a key role in the control of plant water loss. It regulates stomata functioning, carbon dioxide fixation, enzyme activation, and nutrient transport, as well as aiding stress tolerance. Soil potassium reaches plant roots mainly by diffusion, which accounts for 72%-96% of each plant’s requirement.

“Extreme weather events, high temperatures, and droughts have become more frequent because of global warming, and conservationist soil management techniques such as those suggested by the study can mitigate the adverse effects of all this on production,” Echer said. “Inconsistent rainfall may limit crop viability, and because only about 8% of Brazil’s cotton plantations are irrigated, the use of a cover crop is especially important. Straw mulch helps reduce soil temperature, which in turn helps conserve water.”

In western São Paulo, where the experimental farm used in the study is located, the temperature can reach 70°C on cotton plantations without a cover crop (and hence with exposed soil). The use of a cover crop keeps the soil at about 28°C-30°C, conserving soil moisture.

Early application of potassium is widely used in plantations with clayey soil, Echer added, but the technique had not yet been tested on sandy soil with little organic matter, making nutrient retention harder. “Farmers were reluctant to apply fertilizer early in the case of crops planted in sandy soil,” he said. “The study proves that applying potassium to the cover crop maintains yield and improves fiber quality even in sandy soil, which is more fragile, stores less water and makes potassium more susceptible to leaching.”

According to the researchers, the method analyzed in western São Paulo can be replicated in cotton plantations with sandy soil in Mato Grosso (the leading cotton producer in Brazil) and Bahia, as well as in other countries. “The cover crop can be different from the one we used in this study, because the climate may be different, but a precedent has been set for testing new cover species in other parts of the world,” Echer said.

The article “Potassium application to the cover crop prior to cotton planting as a fertilization strategy in sandy soils” (doi: 10.1038/s41598-020-77354-x) by Fábio Rafael Echer, Vinicius José Souza Peres and Ciro Antonio Rosolem can be read at: www.nature.com/articles/s41598-020-77354-x.

Fundação de Amparo à Pesquisa do Estado de São Paulo

Related Potassium Articles from Brightsurf:

Novel potassium channel activator which acts as a potential anticonvulsant discovered
Mount Sinai neuroscience researchers discover a novel potassium channel activator which acts as a potential anticonvulsant.

Effects of potassium fertilization in pear trees
Potassium fertilization effects on quality, economics, and yield in pear orchard.

Potassium metal battery emerges as a rival to lithium-ion technology
In research published in Proceedings of the National Academy of Sciences, researchers from Rensselaer Polytechnic Institute demonstrate how they can overcome a persistent challenge known as dendrites to create a metal battery that performs nearly as well as a lithium-ion battery, but relies on potassium -- a much more abundant and less expensive element.

Altered potassium levels in neurons may cause mood swings in bipolar disorder
A sweeping new set of findings by Salk researchers reveals previously unknown details explaining why some neurons in bipolar patients swing between being overly or under excited.

Sensitive and specific potassium nanosensors to detect epileptic seizures
IBS scientists in collaboration with collaborators at Zhejiang University,have reported a highly sensitive and specific nanosensor that can monitor dynamic changes of potassium ion in mice undergoing epileptic seizures, indicating their intensity and origin in the brain.

Safe potassium-ion batteries
Australian scientists have developed a nonflammable electrolyte for potassium and potassium-ion batteries, for applications in next-generation energy-storage systems beyond lithium technology.

Potassium-driven rechargeable batteries: An effort towards a more sustainable environment
Concerns about the scarcity of lithium and other materials necessary in the now-ubiquitous lithium-ion batteries have recently driven many researchers to look for alternatives, such as sodium and potassium.

Skoltech scientists developed superfast charging high-capacity potassium batteries based on organic
Skoltech researchers in collaboration with scientists from the Institute for Problems of Chemical Physics of RAS and the Ural Federal University showed that high-capacity high-power batteries can be made from organic materials without using lithium or other rare elements.

Alfalfa and potassium: It's complicated
Expect a tradeoff between alfalfa yield and quality when fertilizing with potassium.

There are no water molecules between the ions in the selectivity filter of potassium
Do only potassium ions pass through the selectivity filter of a potassium channel, or are there water molecules between the ions?

Read More: Potassium News and Potassium Current Events
Brightsurf.com is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to Amazon.com.