CASL, Westinghouse simulate neutron behavior in AP1000 reactor core

February 18, 2014

OAK RIDGE, Tenn., Feb. 18, 2014 -- Scientists and engineers developing more accurate approaches to analyzing nuclear power reactors have successfully tested a new suite of computer codes that closely model "neutronics" -- the behavior of neutrons in a reactor core.

Technical staff at Westinghouse Electric Company, LLC, supported by the research team at the Consortium for Advanced Simulation of Light Water Reactors (CASL), used the Virtual Environment for Reactor Applications core simulator (VERA-CS) to analyze its AP1000 advanced pressurized water reactor (PWR). The testing focused on modeling the startup conditions of the AP1000 plant design.

"In our experience with VERA-CS, we have been impressed by its accuracy in reproducing past reactor startup measurements. These results give us confidence that VERA-CS can be used to anticipate the conditions that will occur during the AP1000 reactor startup operations," said Bob Oelrich, manager of PWR Core Methods at Westinghouse. "This new modeling capability will allow designers to obtain higher-fidelity power distribution predictions in a reactor core and ultimately further improve reactor performance."

The AP1000 reactor is an advanced reactor design with enhanced passive safety and improved operational performance that builds on decades of Westinghouse's experience with PWR design. The first eight units are currently being built in China and the United States, and represent the first Generation III+ reactor to receive Design Certification from the U.S. Nuclear Regulatory Commission.

CASL is a U.S. Department of Energy (DOE) Innovation Hub established at Oak Ridge National Laboratory, a part of DOE's National Laboratory System. The consortium core partners are a strategic alliance of leaders in nuclear science and engineering from government, industry and academia.

"At CASL, we set out to improve reactor performance with predictive, science-based, simulation technology that harnesses world-class computational power," said CASL Director Doug Kothe. "Our challenge is to advance research that will allow power uprates and increase fuel burn-up for U.S. nuclear plants. In order to do this, CASL is meeting the need for higher-fidelity, integrated tools."

During the first generation of nuclear energy, performance and safety margins were held at conservative levels as industry and researchers gained experience with the operation and maintenance of what was then a new and complex technology. Over the past 50 years, nuclear scientists and engineers have gained a deeper understanding of the reactor processes, further characterizing nuclear reactor fuel and structure materials.

By making use of newly available computing resources, CASL's research aims for a step increase in the improvements in reactor operations that have occurred over the last several decades.

"CASL has been using modern high-performance computing platforms such as ORNL's Titan, working in concert with the INL Fission computer system, for modeling and simulation at significantly increased levels of detail," said CASL Chief Computational Scientist John Turner. "However, we also recognized the need to deliver a product that is suitable for industry-sized computing platforms."

With this recognition, CASL designed the Test Stand project to try out tools such as VERA-CS in industrial applications. CASL partner Westinghouse was selected as the host for the first trial run of the new VERA nuclear reactor core simulator (VERA-CS). Westinghouse chose a real-world application for VERA-CS: the reactor physics-analysis of the AP1000 PWR, which features a core design with several advanced features. Using VERA-CS to study the AP1000 provides information to further improve the characterization of advanced cores compared to traditional modeling approaches.

Westinghouse's test run on VERA-CS focused on modeling one aspect of reactor physics called "neutronics," which describes the behavior of neutrons in a reactor core. While neutronics is only one of VERA's capabilities, the results provided by VERA-CS for the AP1000 PWR enhance Westinghouse's confidence in their startup predictions and expand the validation of VERA by incorporating the latest trends in PWR core design and operational features.

"VERA-CS exhibited remarkable agreement with plant measurements as well as reference numerical solutions for startup cores, and for these reasons we decided to apply it, successfully, to the AP1000 start-up simulations," said Westinghouse Fellow Engineer Fausto Franceschini.

The CASL team now is working on extending the suite of simulation capabilities to the entire range of operating conditions for commercial reactors, including full-power operation with fuel depletion and fuel cycle reload.
-end-
Further information on the status of VERA-CS development at ORNL's CASL and its deployment at Westinghouse can be obtained by contacting:
ORNL: CASL Director, Douglas Kothe, kothe@ornl.gov
Westinghouse: Fausto Franceschini, Fellow Engineer, FranceF@westinghouse.com

ORNL is managed by UT-Battelle for the Department of Energy's Office of Science. DOE's Office of Science is the single largest supporter of basic research in the physical sciences in the United States, and is working to address some of the most pressing challenges of our time. For more information, please visit http://science.energy.gov. For more information about CASL, please visit http://www.casl.gov/.

The AP1000 PWR is a trademark or registered trademark of the Westinghouse Electric Company LLC, its affiliates and/or its subsidiaries in the United States of America and may be registered in other countries throughout the world. All rights reserved. Unauthorized use is strictly prohibited. Other names may be trademarks of their respective owners.

Image: http://www.ornl.gov/Image%20Library/Main%20Nav/ORNL/News/News%20Releases/2014/casl_westinghouse_highres.jpg?code=767f5e3d-b550-487c-a26a-1778960fc525

Caption: CASL is developing and applying new modeling and simulation technology (Virtual Environment for Reactor Applications Core Simulator or VERA-CS) to resolve and predict the detailed neutron distribution of the power-generation reactor core residing in reactor vessels. Image courtesy of Westinghouse.

NOTE TO EDITORS: You may read other press releases from Oak Ridge National Laboratory or learn more about the lab at http://www.ornl.gov/news. Additional information about ORNL is available at the sites below:
Twitter - http://twitter.com/oakridgelabnews
RSS Feeds - http://www.ornl.gov/ornlhome/rss_feeds.shtml
Flickr - http://www.flickr.com/photos/oakridgelab
YouTube - http://www.youtube.com/user/OakRidgeNationalLab
LinkedIn - http://www.linkedin.com/companies/oak-ridge-national-laboratory
Facebook - http://www.facebook.com/Oak.Ridge.National.Laboratory

DOE/Oak Ridge National Laboratory

Related Behavior Articles from Brightsurf:

Variety in the migratory behavior of blackcaps
The birds have variable migration strategies.

Fishing for a theory of emergent behavior
Researchers at the University of Tsukuba quantified the collective action of small schools of fish using information theory.

How synaptic changes translate to behavior changes
Learning changes behavior by altering many connections between brain cells in a variety of ways all at the same time, according to a study of sea slugs recently published in JNeurosci.

I won't have what he's having: The brain and socially motivated behavior
Monkeys devalue rewards when they anticipate that another monkey will get them instead.

Unlocking animal behavior through motion
Using physics to study different types of animal motion, such as burrowing worms or flying flocks, can reveal how animals behave in different settings.

AI to help monitor behavior
Algorithms based on artificial intelligence do better at supporting educational and clinical decision-making, according to a new study.

Increasing opportunities for sustainable behavior
To mitigate climate change and safeguard ecosystems, we need to make drastic changes in our consumption and transport behaviors.

Predicting a protein's behavior from its appearance
Researchers at EPFL have developed a new way to predict a protein's interactions with other proteins and biomolecules, and its biochemical activity, merely by observing its surface.

Spirituality affects the behavior of mortgagers
According to Olga Miroshnichenko, a Sc.D in Economics, and a Professor at the Department of Economics and Finance, Tyumen State University, morals affect the thinking of mortgage payers and help them avoid past due payments.

Asking if behavior can be changed on climate crisis
One of the more complex problems facing social psychologists today is whether any intervention can move people to change their behavior about climate change and protecting the environment for the sake of future generations.

Read More: Behavior News and Behavior Current Events
Brightsurf.com is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to Amazon.com.