Bending the light with a tiny chip

March 10, 2014

Imagine that you are in a meeting with coworkers or at a gathering of friends. You pull out your cell phone to show a presentation or a video on YouTube. But you don't use the tiny screen; your phone projects a bright, clear image onto a wall or a big screen. Such a technology may be on its way, thanks to a new light-bending silicon chip developed by researchers at Caltech.

The chip was developed by Ali Hajimiri, Thomas G. Myers Professor of Electrical Engineering, and researchers in his laboratory. The results were presented at the Optical Fiber Communication (OFC) conference in San Francisco on March 10.

Traditional projectors--like those used to project a film or classroom lecture notes--pass a beam of light through a tiny image, using lenses to map each point of the small picture to corresponding, yet expanded, points on a large screen. The Caltech chip eliminates the need for bulky and expensive lenses and bulbs and instead uses a so-called integrated optical phased array (OPA) to project the image electronically with only a single laser diode as light source and no mechanically moving parts.

Hajimiri and his colleagues were able to bypass traditional optics by manipulating the coherence of light--a property that allows the researchers to "bend" the light waves on the surface of the chip without lenses or the use of any mechanical movement. If two waves are coherent in the direction of propagation--meaning that the peaks and troughs of one wave are exactly aligned with those of the second wave--the waves combine, resulting in one wave, a beam with twice the amplitude and four times the energy as the initial wave, moving in the direction of the coherent waves.

"By changing the relative timing of the waves, you can change the direction of the light beam," says Hajimiri. For example, if 10 people kneeling in line by a swimming pool slap the water at the exact same instant, they will make one big wave that travels directly away from them. But if the 10 separate slaps are staggered--each person hitting the water a half a second after the last--there will still be one big, combined wave, but with the wave bending to travel at an angle, he says.

Using a series of pipes for the light--called phase shifters--the OPA chip similarly slows down or speeds up the timing of the waves, thus controlling the direction of the light beam. To form an image, electronic data from a computer are converted into multiple electrical currents; by applying stronger or weaker currents to the light within the phase shifter, the number of electrons within each light path changes--which, in turn, changes the timing of the light wave in that path. The timed light waves are then delivered to tiny array elements within a grid on the chip. The light is then projected from each array in the grid, the individual array beams combining coherently in the air to form a single light beam and a spot on the screen.

As the electronic signal rapidly steers the beam left, right, up, and down, the light acts as a very fast pen, drawing an image made of light on the projection surface. Because the direction of the light beam is controlled electronically--not mechanically--it can create a sort of line very quickly. Since the light draws many times per second, the eye sees the process as a single image instead of a moving light beam, says Hajimiri.

"The new thing about our work is really that we can do this on a tiny, one-millimeter-square silicon chip, and the fact that we can do it very rapidly--rapidly enough to form images, since we phase-shift electronically in two dimensions," says Behrooz Abiri, a graduate student in Hajimiri's group and a coauthor on the paper. So far, the images Hajimiri and his team can project with the current version of the chip are somewhat simple--a triangle, a smiley face, or single letters, for example. However, the researchers are currently experimenting with larger chips that include more light-delivering array elements that--like using a larger lens on a camera--can improve the resolution and increase the complexity of the projected images.

In their recent experiments, Hajimiri and his colleagues have used the silicon chip to project images in infrared light, but additional work with different types of semiconductors will also allow the researchers to expand the tiny projector's capabilities into the visible spectrum. "Right now we are using silicon technology, which works better with infrared light. If you want to project visible light, you can take the exact same architecture and do it in what's called compound semiconductor III-V technology," says Firooz Aflatouni, another coauthor on the paper, who in January finished his two-year postdoctoral appointment at Caltech and joined the University of Pennsylvania as an assistant professor. "Silicon is good because it can be easily integrated into electronics, but these other compound semiconductors could be used to do the same thing."

"In the future, this can be incorporated into a phone, and since there is no need for a lens, you can have a phone that acts as a projector all by itself," Hajimiri says. However, although the chip could easily be incorporated into a cell phone, he points out that a tiny projection device can have many applications--including light-based radar systems (called "LIDAR"), which are used in positioning, robotics, geographical measurements, and mapmaking. Such equipment already exists, but current LIDAR technology requires complex, bulky, and expensive equipment--equipment that could be streamlined and simplified to a single chip at a much lower cost.

"But I don't want to limit the device to just a few purposes. The beauty of this thing is that these chips are small and can be made at a very low cost--and this opens up lots of interesting possibilities," he says.

These results were described in a presentation titled "Electronic Two-Dimensional Beam Steering for Integrated Optical Phased Arrays." Along with Hajimiri, Abiri, and Aflatouni, Caltech senior Angad Rekhi also contributed to the work. The study was funded by grants from the Caltech Innovation Initiative, and the Information Science and Technology initiative at Caltech.
-end-


California Institute of Technology

Related Cell Phone Articles from Brightsurf:

Cell phone location used to estimate COVID-19 growth rates
Cell phone location data shows that in counties where activity declined at workplaces and increased at home, coronavirus infection rates were lower.

Study: Anonymized cell phone location data can help monitor COVID-19 growth rates
In a new study published in JAMA Internal Medicine, researchers from Mount Auburn Hospital and the University of Pennsylvania analyzed anonymous, county-level cell phone location data and incidence of COVID-19.

To make a good impression, leave cell phone alone during work meetings
New hires especially should keep their cell phones stashed away during business meetings, a new study strongly implies.

Flat-panel technology could transform antennas, wireless and cell phone communications
Researchers at Los Alamos National Laboratory are reinventing the mirror, at least for microwaves, potentially replacing the familiar 3-D dishes and microwave horns we see on rooftops and cell towers with flat panels that are compact, versatile, and better adapted for modern communication technologies.

Cell phone injuries
Cell phones are mainstays of daily life. This observational study analyzed 20 years of data on people who went to emergency departments with head and neck injuries from cell phone use to estimate the number of injuries, learn what types of injuries there were, and understand how the injuries occurred, such as from distracted driving or walking.

Cell phone-based microscope leads to possible strategy for treating river blindness
River blindness, or onchocerciasis, is a disease caused by a parasitic worm (Onchocerca volvulus) found primarily in Africa.

Cell phone data coupled with sewage testing show drug use patterns
The drugs people inhale, inject or ingest ultimately end up in some form down the toilet.

Cell phone use and distracted driving begins in the mind
Even simple cell phone conversations can cause distracted driving. Researchers have found listening on the phone while driving creates a lag in the mind to extract itself from one object before fixing attention on another object.

What motivates parents to protect children from cell phone addiction?
A new study examined the role parental mediation can play in protecting children from the potential negative effects of smartphone use, comparing the perceived risk and different types of mediation and parenting styles.

Catching the IMSI-catchers: SeaGlass brings transparency to cell phone surveillance
University of Washington security researchers have developed a new system called SeaGlass to detect anomalies in the cellular landscape that can indicate where and when IMSI-catchers, cell-site simulators and other devices used in cell phone surveillance are present.

Read More: Cell Phone News and Cell Phone Current Events
Brightsurf.com is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to Amazon.com.