Nav: Home

Faster than the speed of sound: New control system has what it takes to guide experimental aircraft

April 29, 2009

COLUMBUS, Ohio -- When a jet is flying faster than the speed of sound, one small mistake can tear it apart.

And when the jet is so experimental that it must fly unmanned, only a computer control system can pilot it.

Ohio State University engineers have designed control system software that can do just that -- by adapting to changing conditions during a flight.

Government agencies have been developing faster-than-sound vehicles for decades. The latest supersonic combustion ramjets -- called scramjets -- burn air for fuel, and could one day carry people to space or around the world in a matter of hours.

The recent success of NASA's X-43 hypersonic jet has spurred research into the control systems for these vehicles, said Lisa Fiorentini, doctoral student in electrical and computer engineering at Ohio State University.

She and associate professor Andrea Serrani are developing a new control system in collaboration with the U.S. Air Force Research Laboratory (ARFL) at Wright-Patterson Air Force Base in Ohio.

In the current issue of the Journal of Guidance, Control, and Dynamics, they report that their controller performed flawlessly in computer simulations of flight maneuvers.

The controller both guides the jet along its trajectory and keeps it stable during a flight, Fiorentini explained. Sensors measure factors such as altitude, velocity, and acceleration, and the controller calculates whether any adjustments need to be made to keep the jet stable and on course. Then actuators carry out the controller's commands -- for instance, throttling up the engine if the jet needs to accelerate.

"Because these vehicles are unmanned right now, we have to prepare everything ahead of time -- anticipate every possible in-flight event," she said.

"And the controller has to work really fast. At 10 times the speed of sound, if you lose just one second, the jet has gone far, far off course."

What sets the Ohio State control system apart, Serrani explained, is that it allows for flexibility: it adapts to changing conditions during a flight.

"The truly remarkable feature of our approach is that we consider a realistic, physics-based vehicle model within our stability analysis, using a highly sophisticated controller," he said.

Most other research teams build their controllers from very simplified computer models, Fiorentini added.

"Since we are working with Wright-Patterson, we have access to the most sophisticated model available for this aircraft," she said.

They are collaborating with Michael A. Bolender, an aerospace engineer, and David B. Doman, a senior aerospace engineer, both of ARFL, as well as Jack McNamara, assistant professor of aerospace engineering at Ohio State.

The Ohio State engineers derived equations that describe a scramjet's flight dynamics and behavior. Then, given the vehicle model by their partners at Wright-Paterson, they created a set of algorithms that could ultimately be built into a scramjet's on-board computer.

Today's experimental scramjets are not merely supersonic -- meaning they fly faster than the speed of sound, or Mach 1 -- but hypersonic, meaning they fly at Mach 5 or faster. The most recent X-43 flight in 2004 neared a speed of Mach 10 (Mach 9.8, or 7,546 miles per hour).

Scramjets are shaped to scoop oxygen from the atmosphere during flight in order to ignite the hydrogen fuel already on board. This eliminates the need for heavy external oxygen tanks, and enables scramjets to carry more cargo than a typical rocket.

NASA had explored scramjets as a successor to the Space Shuttle for trips to the International Space Station. The X-43 project closed in 2004, as the space agency shifted its priorities toward a return to the Moon.

But the technology is still under development in military and commercial sectors. Scramjets could deliver missiles to mobile targets; they could also carry people halfway around the world in less than an hour.

For this study, the engineers simulated two flight situations. In the first, simpler case, the scramjet had to climb from a level flight to 13,000 feet in a little less than six minutes. In a second, more complicated maneuver, it had to start at a few degrees off-kilter from a level flight, and then climb 25,000 feet in about four minutes.

In both simulations, researchers recorded the controller's tracking errors as the jet executed its maneuver. Then they compared the results to simulations using a controller they had developed previously -- one that did not have adaptive capabilities built in.

For example, in the simpler maneuver, the largest altitude tracking error for the older, non-adaptive controller was just over 40 feet; the largest corresponding error for the new, adaptive controller was less than 2 feet - an improvement by a factor of 20.

For the more complex maneuver, the non-adaptive controller failed -- the simulated jet spun out of control and crashed in less than four seconds. The new adaptive controller was able to guide the jet to its new altitude without incident.

The Ohio State and AFRL engineers are continuing to refine the controller. The next improvement will add some safety limits, Fiorentini said. Scramjets need to maintain the right amount of airflow to the engine, she explained, and if they rise too fast, the engine may stall in mid-air.
-end-
This work was funded by the ARFL and the U.S. Air Force Office of Scientific Research through the Ohio State University Collaborative Center of Control Science, and by the Michigan/AFRL Collaborative Center of Control Science.

Contact: Andrea Serrani, (614) 292-4976; Serrani.1@osu.edu

Lisa Fiorentini; Fiorentini.2@osu.edu

Written by Pam Frost Gorder, (614) 292-9475; Gorder.1@osu.edu

Ohio State University

Related Fly Articles:

Baby pterodactyls could fly from birth
A breakthrough discovery has found that pterodactyls, extinct flying reptiles also known as pterosaurs, had a remarkable ability -- they could fly from birth.
New insights into genetics of fly longevity
Alexey Moskalev, Ph.D., Head of the Laboratory of Molecular Radiobiology and Gerontology Institute of Biology, and co-authors from the Institute of biology of Komi Science Center of RAS, Engelgard's Institute of molecular biology, involved in the study of the aging mechanisms and longevity of model animals announce the publication of a scientific article titled: 'The Neuronal Overexpression of Gclc in Drosophila melanogaster Induces Life Extension With Longevity-Associated Transcriptomic Changes in the Thorax' in Frontiers in Genetics - a leading open science platform.
Researchers build an artificial fly brain that can tell who's who
CIFAR researchers have built a neural network that mimics the fruit fly's visual system and can distinguish and re-identify flies.
Understanding the neurological code behind how flies fly
Discoveries about the neurological processes by which flies stay steady in flight by researchers at Case Western Reserve University could help humans build more responsive drones or better-balanced robots.
Parasites discovered in fossil fly pupae
Parasitic wasps existed as early as several million years ago.
Fruit fly species can learn each other's dialects
Fruit flies from different species can warn each other when parasitic wasps are near.
Stopping a tiny -- and deadly -- fly in its tracks
New research presents a technique that could help treat African sleeping sickness, which impacts millions in sub-Saharan Africa and -- in its late stages -- can be fatal.
New insights into the inner clock of the fruit fly
Biologists around Professor Ralf Stanewsky (University of Münster, Germany) have now presented new findings on the inner workings of circadian clocks in the fruit fly.
Programming drones to fly in the face of uncertainty
MIT CSAIL system enables drones to fly through forests and avoid obstacles by harnessing uncertainty.
The strange case of the scuba-diving fly
How a species of fly subverted nature to forage in a caustic underwater habitat.
More Fly News and Fly Current Events

Top Science Podcasts

We have hand picked the top science podcasts of 2019.
Now Playing: TED Radio Hour

Accessing Better Health
Essential health care is a right, not a privilege ... or is it? This hour, TED speakers explore how we can give everyone access to a healthier way of life, despite who you are or where you live. Guests include physician Raj Panjabi, former NYC health commissioner Mary Bassett, researcher Michael Hendryx, and neuroscientist Rachel Wurzman.
Now Playing: Science for the People

#543 Give a Nerd a Gift
Yup, you guessed it... it's Science for the People's annual holiday episode that helps you figure out what sciency books and gifts to get that special nerd on your list. Or maybe you're looking to build up your reading list for the holiday break and a geeky Christmas sweater to wear to an upcoming party. Returning are pop-science power-readers John Dupuis and Joanne Manaster to dish on the best science books they read this past year. And Rachelle Saunders and Bethany Brookshire squee in delight over some truly delightful science-themed non-book objects for those whose bookshelves are already full. Since...
Now Playing: Radiolab

An Announcement from Radiolab