Researcher: Feeding distiller's grains vital to future of livestock operation success

July 06, 2007

AMARILLO - There's no reason the cattle-feeding industry in Texas cannot remain strong and viable if it incorporates distiller's grains into rations, said a Texas Agricultural Experiment Station researcher.

"Our concern has been 'Will there be enough feed"'," said Dr. Jim MacDonald, Experiment Station beef cattle nutritionist. "Assuming all the distiller's grains are available for livestock feed, clearly there will be."

But, MacDonald said, the ratio of corn being fed vs. distiller's grains could go from 11-to-1 today to 3-to-1 nationally in the next 10 years.

"So we'd better figure out how to feed distiller's grains," he said.

Relatively few distiller's grains are fed in the Southern Plains states now, MacDonald said. Some beef producers are reluctant because there's no incentive and no ready supply.

However, with the opening of two ethanol plants scheduled later this year in the Panhandle, a steady supply of distiller's grains should be available, making the alternative feedstock more attractive, he said.

"In the future, as long as it is priced relative to corn, I think there will be a necessity to use this new large pool of feed," MacDonald said.

The proportion of corn used from 2002 to 2006 hasn't changed much in the areas of human consumption, high fructose production or exports, he said.

The biggest change has been corn moving from the livestock-feed sector to the fuel-ethanol sector, MacDonald said. Livestock feed has decreased from 60 percent to 55 percent in that time period, while the ethanol fuel sector increased from 8 percent to 14 percent.

However, National Corn Growers Association forecasts show that while the percentage has decreased, the actual bushels of corn produced will continue to increase due to higher yields and acres planted, he said.

The acres of corn harvest is expected to rise from the current 71 million to 80-85 million over the next five years, MacDonald said. Yields are projected to rise from about 150 bushels per acre to almost 180 bushels per acre in the next 10 years.

"We're not sure how big the ethanol industry is going to get, but if every plant being proposed as of now gets built, the Renewable Fuels Association says we'll be producing 12.5 billion gallons of ethanol a year from starch," he said.

In estimating feed availability for livestock, MacDonald assumed as much as 15 billion gallons of ethanol being produced annually. At that rate, 35.5 percent of all corn would be needed for ethanol. This would bring the amount of corn available for feed down from the current 60 percent to 33.5 percent, assuming the other categories remain steady.

Because yields are expected to increase, he said the decrease of actual corn fed will not be as dramatic, going from 6.1 billion bushels in 2006 to 5 billion bushels by 2017.

The beef and dairy industries are in the best position of any of the livestock industry to use distiller's grains, MacDonald said.

Based on the number of plants proposed in the Texas High Plains, he estimated feed yards will need to include 15 percent to 20 percent of distiller's grains in the diet (moisture-free basis) to use all the available supply.

The two Hereford plants, with a combined 200 million gallons of ethanol production per year, will produce 665,000 tons of distiller's grains, he said. This quantity alone would be enough to include 6 percent to 7 percent distiller's grains in the diets of the 5.75 million head of cattle fed in the Texas, New Mexico and Oklahoma region.

If a proportion higher than 20 percent were included into area feed yard and dairy rations, distiller's grains will need to be railed in from the Midwest, he said.

Growth of the ethanol industry in the Corn Belt has created a greater demand for corn in that area, MacDonald said. However, they now have a large surplus distiller's grains. That could make them cheaper to rail into Texas than whole corn.

"The only thing that keeps this all in balance is our ability to utilize the distiller's grains," MacDonald said. "We still have to go through the learning curve of how to feed them."

In the tri-state area, distiller's grains would be mixed with steam-flaked corn. This is different from in the Midwest, where dry-rolled corn is fed, he said.

Several studies are under way to see how to maximize the use of distiller's grains in the feed yard situation, MacDonald said. Those results should be available later this summer.
-end-


Texas A&M AgriLife Communications

Related Ethanol Articles from Brightsurf:

Spraying ethanol to nanofiber masks makes them reusable
A joint research team from POSTECH and Japan's Shinshu University evaluates the filtration efficiency of nanofiber and melt-blown filters when cleaned with ethanol.

Anaerobically disinfect soil to increase phosphorus using diluted ethanol
Anaerobic disinfection of soil is an effective method to kill unwanted bacteria, parasites and weeds without using chemical pesticides.

Fractionation processes can improve profitability of ethanol production
The US is the world's largest producer of bioethanol as renewable liquid fuel, with more than 200 commercial plants processing over 16 billion gallons per year.

Ethanol fuels large-scale expansion of Brazil's farming land
A University of Queensland-led study has revealed that future demand for ethanol biofuel could potentially expand sugarcane farming land in Brazil by 5 million hectares by 2030.

Measuring ethanol's deadly twin
ETH Zurich researchers have developed an inexpensive, handheld measuring device that can distinguish between methanol and potable alcohol.

Modified enzyme can increase second-generation ethanol production
Using a protein produced by a fungus that lives in the Amazon, Brazilian researchers developed a molecule capable of increasing glucose release from biomass for fermentation.

Scientists develop a chemocatalytic approach for one-pot reaction of cellulosic ethanol
Scientists at the Dalian Institute of Chemical Physics (DICP) of the Chinese Academy of Sciences have developed a chemocatalytic approach to convert cellulose into ethanol in a one-pot process by using a multifunctional Mo/Pt/WOx catalyst.

New core-shell catalyst for ethanol fuel cells
Scientists at Brookhaven Lab and the University of Arkansas have developed a highly efficient catalyst for extracting electrical energy from ethanol, an easy-to-store liquid fuel that can be generated from renewable resources.

Yeast makes ethanol to prevent metabolic overload
Why do some yeast cells produce ethanol? Scientists have wondered about this apparent waste of resources for decades.

Corncob ethanol may help cut China's greenhouse gas emissions
A new Biofuels, Bioproducts and Biorefining study has found that using ethanol from corncobs for energy production may help reduce greenhouse gas emissions in China, if used instead of starch-based ethanol.

Read More: Ethanol News and Ethanol Current Events
Brightsurf.com is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to Amazon.com.