A Mismatch Made In Heaven

August 13, 1997

A perfect match may be a blessing in love or marriage, but in materials science a slight mismatch may sometimes help achieve the best results. Researchers at the Weizmann Institute have shown that by manipulating the mismatch between the spacing of atoms in two materials they can control the size of microscopic semiconductor crystals.

The finding holds a possible key to the development of tiny semiconductors with new optoelectronic properties for basic research and for tomorrow's optics and electronics industries. This is because the properties of crystals smaller than approximately 10 nanometers, or 10 millionths of a millimeter, can be altered by merely changing their dimensions.

This research was conducted by Dr. Gary Hodes, Prof. Israel Rubinstein and then doctoral student Yuval Golan, all of the Materials and Interfaces Department, and was described in a series of papers, the most recent two published in Advanced Materials.

Using a technique called electrodeposition, the scientists laid down crystals of the semiconductor cadmium selenide, each measuring four to five nanometers, onto a gold substrate. The crystals were found to be oriented in a uniform manner. This configuration is highly beneficial for controlling the semiconductor properties and it occurs because the atoms of the crystals tend to align themselves with the atoms in the surface layer of the substrate. Such alignment is attributed to the good match between the interatomic spacings of cadmium selenide crystals and of gold.

"We now run into what might at first glance seem to be a paradox," says Hodes. "On the one hand, attaining a close match is the important first step leading to crystal alignment. On the other hand, the match is not perfect - but this imperfection can also be made to work to our advantage. In fact," he says, "it is the small remaining mismatch that allows for precise control over crystal size."

The substrate "stretches" the growing crystal in an attempt to minimize the mismatch, creating a strain within the crystal that eventually causes it to stop growing altogether. Therefore, by fine-tuning the mismatch the scientists were able to determine when the crystal will stop growing, in other words, its size.

They showed that the addition of small amounts of a material called tellurium to the semiconductor reduced the mismatch to a predictable degree. This allowed them to produce uniformly oriented crystals of varying sizes. "Compared with alternative approaches, our method is much simpler and cheaper and makes it possible to control the size of smaller crystals," says Rubinstein.The research of Prof. Rubinstein and Dr. Hodes was supported by the U.S. Office of Naval Research.
-end-


American Committee for the Weizmann Institute of Science

Related Crystals Articles from Brightsurf:

A new method to measure optical absorption in semiconductor crystals
Tohoku University researchers have revealed more details about omnidirectional photoluminescence (ODPL) spectroscopy - a method for probing semiconducting crystals with light to detect defects and impurities.

Fat crystals trigger chronic inflammation
A congenital disorder of the fat metabolism can apparently cause chronic hyperreaction of the immune system.

First ever observation of 'time crystals' interacting
For the first time ever, scientists have witnessed the interaction of a new phase of matter known as 'time crystals'.

'Blinking" crystals may convert CO2 into fuels
Imagine tiny crystals that ''blink'' like fireflies and can convert carbon dioxide, a key cause of climate change, into fuels.

Laser takes pictures of electrons in crystals
Microscopes of visible light allow to see tiny objects as living cells and their interior.

Rubies on sapphire: Recipe for making crystals in flux
The effect of the holding temperature and solubility curve of rubies was elucidated, for Al2O3:Cr in MoO3 from 1050 to 1200.

Transparency discovered in crystals with ultrahigh piezoelectricity
Use of an AC rather than a DC electric field can improve the piezoelectric response of a crystal.

New photonic liquid crystals could lead to next-generation displays
A new technique to change the structure of liquid crystals could lead to the development of fast-responding liquid crystals suitable for next generation displays -- 3D, augmented and virtual reality -- and advanced photonic applications such as mirrorless lasers, bio-sensors and fast/slow light generation, according to an international team of researchers from Penn State, the Air Force Research Laboratory and the National Sun Yat-sen University, Taiwan.

The secret behind crystals that shrink when heated
Scientists at Brookhaven Lab have new experimental evidence and a predictive theory that solves a long-standing materials science mystery: why certain crystalline materials shrink when heated.

Engineered protein crystals make cells magnetic
If scientists could give living cells magnetic properties, they could perhaps manipulate cellular activities with external magnetic fields.

Read More: Crystals News and Crystals Current Events
Brightsurf.com is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to Amazon.com.