Abrupt wing stall

September 30, 2003

When a fighter pilot engages an enemy at near sonic speeds, abrupt wing stall is definitely not part of his flight plan. Yet for the past 50 years, all aircraft that can operate at velocities near the speed of sound, and angles of attack near maximum lift, have experienced some form of uncommanded lateral motion - where the aircraft undergoes a one-sided or side-to-side upset from the intended direction of flight. At the very least, it causes loss of advantage. At its worst, it could result in a loss of the aircraft.

"This is not the first time this aerodynamic behavior has been seen" notes Lawrence Ash, the Office of Naval Research program manager leading a national study. "It can sometimes be fixed by modifications to the aircraft flight control system.

But on the F/A-18E/F jet fighter prototypes, the motion happened so quickly and in such a narrow range of the operating envelope that the computer-driven flight control system wasn't able to compensate for it in time.

The question was: why did the F/A-18E/F jet fighters experience abrupt wing stall (AWS) when the F/A-18C/D jet fighters did not?" It was the same question that a Secretary of Defense-commissioned Blue Ribbon Panel asked.

The Blue Ribbon Panel called for a national research effort to: (1) understand the aerodynamic phenomena causing abrupt wing stall, (2) develop test and analysis methods to predict it, (3) characterize and quantify the severity of an AWS event, and (4) develop modeling and simulation procedures to assess the impact of an AWS encounter on an aircraft's flying qualities.

In response, the Office of Naval Research formed a team of scientists and engineers from NASA, the Naval Air Systems Command (NAVAIR), the Air Force Research Laboratory (AFRL), and several universities and government contractors to study the problem.

The team made use of all the nation's data on aircraft - both existing and historical - capable of operating at airspeeds near and beyond the speed of sound. With support from the F/A-18, AV-8B, and F-16 program offices, and the Department of Defense High Performance Computing Modernization Office, the team conducted high-speed wind tunnel tests, performed hundreds of computational fluid dynamics calculations, and conducted both piloted and un-piloted simulations of AWS models.

An AWS simulation model was developed and flown on a NAVAIR flight simulator by the Navy's F/A-18E/F chief test pilot. Both qualitative and quantitative simulation data were compared with actual flight test results. The effort required five years. "It was a fairly aggressive research schedule," says Ash, " And ultimately we were successful."

The team developed new tools and procedures for an early assessment of an aircraft's susceptibility to AWS. These include experimental, computational, simulation, and flight test figures of merit that can indicate if a new aircraft design will be vulnerable to AWS anywhere in its flight envelope.

The results of their study were presented in 18 papers at the American Institute of Aeronautics and Astronautics 41st Aerospace Sciences Meeting in January 2003, and will be published in two upcoming special editions of the AIAA Journal of Aircraft.

"I'm confident," Ash says, "that future aircraft programs can make use of these modeling and simulation tools to screen their new wing designs for a susceptibility to AWS earlier in their development phase, allowing any required modifications to the aircraft to be much less expensive, and less time consuming to undertake."
-end-


Office of Naval Research

Related Aircraft Articles from Brightsurf:

University of South Carolina redefining aircraft production process
The University of South Carolina College of Engineering and Computing will transform the manufacturing and simulation processes used in aircraft production through a $5.7 million NASA grant.

Small altitude changes could cut climate impact of aircraft by up to 59%
Altering the altitudes of less than 2% of flights could reduce contrail-linked climate change by 59%, says a new Imperial study.

Small altitude changes could cut the climate impact of aircraft
Contrails -- the white, fluffy streaks in the sky that form behind planes -- can harm the environment.

New electrodes could increase efficiency of electric vehicles and aircraft
The rise in popularity of electric vehicles and aircraft presents the possibility of moving away from fossil fuels toward a more sustainable future.

Composite metal foam outperforms aluminum for use in aircraft wings
The leading edges of aircraft wings have to meet a very demanding set of characteristics.

Particulate matter from aircraft engines affects airways
In a unique, innovative experiment, researchers under the leadership of the University of Bern have investigated the effect of exhaust particles from aircraft turbine engines on human lung cells.

How to ice-proof the next generation of aircraft
To prevent ice formation on aircraft during flight, current systems utilize the heat generated by burning fuel, but these high-temperature, fuel-dependent systems cannot be used on the proposed all-electric, temperature-sensitive materials of next-generation aircraft.

Putting hybrid-electric aircraft performance to the test
Although hybrid-electric cars are becoming commonplace, similar technology applied to airplanes comes with significantly different challenges.

Aircraft microbiome much like that of homes and offices, study finds
What does flying in a commercial airliner have in common with working at the office or relaxing at home?

Sequential model chips away at mysteries of aircraft
Ice accumulation on aircraft wings is a common contributing factor to airplane accidents.

Read More: Aircraft News and Aircraft Current Events
Brightsurf.com is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to Amazon.com.