INEEL researchers clean plutonium from soil using carbon dioxide

October 11, 2001

Even dirt can be dirty, and researchers have found a way to clean soil contaminated with two radioactive elements produced by past nuclear weapons development and nuclear energy research. The method takes advantage of an industrial process called supercritical fluid extraction to clean up long-lived radioactivity that could persist well after the hills have crumbled. Potentially, this method could help the nuclear industry and the federal government clean up contaminated soil.

INEEL researchers used pressurized, heated carbon dioxide and an added metal binding chemical compound to clean radioactively contaminated soil. The method removed more than 69 percent of the plutonium and americium from spiked, local soil, report two chemists from the U.S. Department of Energy's Idaho National Engineering and Environmental Laboratory in the October 2001 issue of Radiochemica Acta. Supercritical fluid extraction is already used to decaffeinate coffee, purify spices and dry clean clothes -- and has been shown to remove plutonium from stainless steel -- but this is the first time it has been used to remove plutonium from soil.

Supercritical fluid extraction is industrially safe and environmentally friendly. For these experiments, carbon dioxide and soil were mixed, heated and pressurized. Under these conditions, carbon dioxide flows like a gas, dissolves like a liquid, but behaves with chemical properties unlike gases or liquids. A chemical agent added to the carbon dioxide flowed through the soil and grabbed the plutonium and americium, whisking the compound back into the fluid-like carbon dioxide.

The carbon dioxide was then shunted out of the soil and depressurized, dropping the compound into a vial on its way back into the atmosphere. In an industrial-scale setting, the carbon dioxide would be recycled. Also, the researchers added ethanol and can add different chemical agents to improve the efficiency of extraction.

Unlike harsher methods of extraction, supercritical fluid extraction leaves the soil intact, making it suitable for cleaning up plutonium-contaminated soil at DOE sites. "The DOE has the technology to isolate plutonium contaminated soils. However, there are no effective extraction technologies for removing strongly adsorbed and recalcitrant radionuclides from soil," INEEL chemist Robert Fox said. "They tried nitric acid extraction, but that dissolved 25 percent of the soil mass. They weren't left with anything resembling soil after the extraction." In fact, he explained, dissolving soil in nitric acid creates a radioactive sludge that must still be disposed of.

In contrast, the supercritical extraction method is nondestructive-no soil mass is lost in the process. How effectively this supercritical fluid extraction removes radioactive elements from soil depends partly on the chemistry of the soil. Though a handful of soil looks uniform, soil particles are made up of minerals from both rocks and clay, which react differently with the radioactive elements. Also, the plutonium that is bound near the surface of a particle is easier to remove than that bound inside the mineral lattice.

The efficiency of the process on the INEEL soil surprised the authors of the study. Said INEEL chemist Bruce Mincher, "We didn't think we'd get such high percentages right off the bat. Plutonium is fairly difficult to remove sometimes. I thought we'd get the easy plutonium. We perhaps got the plutonium that migrated into the mineral lattices of the soil, where it's almost impossible to get out."

In fact, Mincher said the amount of radioactivity left on the soil is below the levels required by the government for clean up, in spite of the fact that the spiked sample started out with more radioactivity than is commonly found on INEEL soil.

"Our follow-up experiments removed almost 100 per cent of the americium and plutonium," said coauthor Robert Fox. "Someone needs to give us a harder problem or a harder sample."

Since actual contaminated INEEL soil was unavailable for this initial work, the chemists spiked clean INEEL soil with the two radioactive materials. They verified that the spiked soil resembled real contaminated soil by subjecting the spiked soil to the same characterization method that has been used on contaminated INEEL soil previously.

Based on their characterization of the spiked soil, the researchers found that it was a suitable surrogate for a real-world sample. However, weather and age can affect the chemistry of the materials bound to the soil, a criticism the two chemists readily acknowledge.

"The obvious next step is to obtain real-world samples and demonstrate the method is effective on all manner of soils," said Fox. "We also want to have a fundamental understanding of the chemistry that occurs -- why does it work that way, and what is inhibiting it from working faster and better."

Mincher and Fox were funded to investigate plutonium extraction by the BNFL Group. BNFL Group's subsidiary BNFL, Inc. is the company contracted by DOE to run INEEL's Advanced Mixed Waste Facility. BNFL, Inc. is always looking for inexpensive, practical technologies to clean up contaminated materials such as those found at the Radioactive Waste Management Complex at INEEL's desert site.

Use of supercritical carbon dioxide in industry goes back to the 1920s, when it was first used to extract asphalt from oil. Since then, it has been used to remove the caffeine from coffee beans and as an alternative to hazardous dry cleaning solvents. Since the methods are industrially mature, Fox and Mincher expect scaling up the method would be relatively easy.
The INEEL is a science-based, applied engineering national laboratory dedicated to supporting the U.S. Department of Energy's missions in national security, environment, energy and science. The INEEL is operated for the DOE by Bechtel BWXT Idaho, LLC, in partnership with the Inland Northwest Research Alliance.

Technical contact: Bruce Mincher, 208-533-4449
Robert Fox, 208-526-7844

Visit out web site at

DOE/Idaho National Laboratory

Related Nitric Acid Articles from Brightsurf:

Model for acid-tolerant yeast helps guide industrial organic acid production
Microbes and other microscopic organisms could serve as sustainable ''factories'' to create many types of industrial materials because they naturally convert nutrients such as sugars into byproducts.

Nitric oxide a possible treatment for COVID-19
Researchers at Uppsala University have found that an effective way of treating the coronavirus behind the 2003 SARS epidemic also works on the closely related SARS-CoV-2 virus, the culprit in the ongoing COVID-19 pandemic.

Benefits of inhaled nitric oxide therapy for pregnant patients with COVID-19
Inhaled nitric oxide (NO) can be a valuable adjunct respiratory therapy for pregnant women with severe and critical COVID-19.

Nitric oxide may slow progression of COVID-19
Researchers at the George Washington University and Albert Einstein College of Medicine published a review in the journal Nitric Oxide suggesting that nitric oxide treatment can be pivotal in the fight against SARS-CoV-2.

Uncuffing nitric oxide production: Beta-arrestin2 complexes regulate NO levels
In a new report, researchers at the Medical University of South Carolina have uncovered one of the mechanisms regulating the production of nitric oxide (NO) in liver endothelial cells.

Researchers discover a link between two important products of nitric oxide
Oxide plays a key role in cardiovascular and neurodegenerative diseases as well as cancer.

Nitric oxide-scavenging hydrogel developed for rheumatoid arthritis treatment
The research team of POSTECH utilized NO-cleavable-crosslinker that reacts to NO and developed a NO-scavenging nano-sized hydrogel (NO-Scv gel).

Microbes can grow on nitric oxide
Nitric oxide (NO) is a central molecule of the global nitrogen cycle.

Nitric acid and ammonia electrosynthesis
The commercial synthesis methods for HNO3 and NH3 chemicals is Ostwald and Haber-Bosch process, respectively, but both of them are energy-intensive and high-emission.

Diabetic foot ulcers heal quickly with nitric oxide technology
Around the world, 425 million people live with diabetes and upwards of 15 percent develop foot ulcers, which increases their risk of death 2.5 times.

Read More: Nitric Acid News and Nitric Acid Current Events is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to