Working under pressure: Diamond micro-anvils with huge pressures will create new materials

October 18, 2016

BIRMINGHAM, Ala. - University of Alabama at Birmingham researchers will use pressures greater than those found at the center of the Earth to potentially create as yet unknown new materials. In the natural world, such immense forces deep underground can turn carbon into diamonds, or volcanic ash into slate.

The ability to produce these pressures depends on tiny nanocrystalline-diamond anvils built in a UAB clean room manufacturing facility. Each anvil head is just half the width of an average human hair. The limits of their pressure have not yet been reached as the first 27 prototypes are being tested.

"We have achieved 75 percent of the pressure found at the center of the Earth, or 264 gigapascals, using lab-grown nanocrystalline-diamond micro-anvil," said Yogesh Vohra, Ph.D., a professor and university scholar of physics in the UAB College of Arts and Sciences. "But the goal is one terapascal, which is the pressure close to the center of Saturn. We are one-quarter of the way there."

One terapascal, a scientific measure of pressure, is equal to 147 million pounds per square inch.

One key to high pressure is to make the point of the anvil, where the pressure is applied, very narrow. This magnifies the pressure applied by a piston above the micro-anvil, much like the difference of being stepped on by a spiked high heel rather than a loafer.

A more difficult task is how to make an anvil that is able to survive this ultra-high pressure. The solution for the Vohra team is to grow a nanocrystalline pillar of diamond -- 30 micrometers wide and 15 micrometers tall -- on the culet of a gem diamond. The culet is the flat surface at the bottom of a gemstone.

"We didn't know that we could grow nanocrystalline diamonds on a diamond base," Vohra said. "This has never been done before."

In the 264-gigapascal pressure test at Argonne National Laboratory in Lemont, Illinois, the nanocrystalline diamond showed no sign of deformation. Vohra and colleagues recently reported this result in the American Institute of Physics journal AIP Advances.

"The structure did not collapse when we applied pressure," Vohra said. "Nanocrystalline diamond has better mechanical properties than gem diamonds. The very small-sized grain structure makes it really tough."

As more micro-anvils are tested and improved, they will be used to study how transition metals, alloys and rare earth metals behave under extreme conditions. Just as graphitic carbon that is subjected to high pressure and temperature can turn into diamond, some materials squeezed by the micro-anvils may gain novel crystal modifications with enhanced physical and mechanical properties -- modifications that are retained when the pressure is released. Such new materials have potential applications in the aerospace, biomedical and nuclear industries.

The micro-anvils are made in a Class 7000 clean room in the UAB Diamond Microfabrication Lab, using maskless lithography and microwave plasma chemical vapor deposition.

Vohra says his research team wants to generate smaller grain sizes in the nanocrystalline diamond, which may make it even stronger; understand how the nanocrystalline diamond is bonded to the gem diamond; and use ion beams to machine the top of the micro-anvil to a hemispherical shape. That shape will mean an even narrower contact point, thus increasing the pressure.

Testing is done at Argonne because it has a very bright synchrotron X-ray source that can probe crystal structure of micron-sized materials under pressure. Vohra and two graduate students travel to Argonne about four times a year.
-end-
Besides Vohra, authors of the AIP Advances paper, "Nanocrystalline diamond micro-anvil grown on single crystal diamond as a generator of ultra-high pressures," are Gopi K. Samudrala, Samuel L. Moore, Georgiy M. Tsoi, Paul A. Baker, all of the UAB Department of Physics; and Nenad Velisavljevic, Los Alamos National Laboratory, New Mexico.

University of Alabama at Birmingham

Related Volcanic Ash Articles from Brightsurf:

Volcanic ash could help reduce CO2 associated with climate change
University of Southampton scientists investigating ways of removing carbon dioxide (CO2) and other greenhouse gases from our atmosphere believe volcanic ash could play an important role.

Volcanic ash may have a bigger impact on the climate than we thought
Volcanic ash shuts down air traffic and can sicken people.

Ash dieback is less severe in isolated ash trees
New research published in the British Ecological Society's Journal of Ecology finds that ash dieback is far less severe in the isolated conditions ash is often found in, such as forests with low ash density or in open canopies like hedges, suggesting the long term impact of the disease on Europe's ash trees will be more limited than previously thought.

Lead isotopes a new tool for tracking coal ash
Duke University scientists have developed a forensic tracer that uses lead isotopes to detect and measure coal fly ash in dust, soil and sediments.

Volcanic ash sparks a new discovery
Imagine you're getting ready to fly to your favorite vacation destination when suddenly a volcano erupts, sending massive amounts of volcanic ash into the atmosphere, and forcing the cancellation of your flight.

Ash tree species likely will survive emerald ash borer beetles, but just barely
'Lingering ash.' That's what the US Forest Service calls the relatively few green and white ash trees that survive the emerald ash borer onslaught.

Ash dieback is predicted to cost £15 billion in Britain
A team of researchers from the University of Oxford, Fera Science, Sylva Foundation and the Woodland Trust has calculated the true economic cost of ash dieback -- and the predictions, published today in Current Biology, are staggering.

Mysterious volcanic ash layer from 29,000 years ago traced to volcano in Naples
Mysterious volcanic ash layer blanketing the Mediterranean 29,000 years ago traced to volcano in Naples, Italy.

How bacteria can help prevent coal ash spills
Researchers have developed a technique that uses bacteria to produce 'biocement' in coal ash ponds, making the coal ash easier to store and limiting the risk of coal ash spills into surface waters.

Wildfire ash could trap mercury
In the summers of 2017 and 2018, heat waves and drought conditions spawned hundreds of wildfires in the western US and in November, two more devastating wildfires broke out in California, scorching thousands of acres of forest, destroying homes and even claiming lives.

Read More: Volcanic Ash News and Volcanic Ash Current Events
Brightsurf.com is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to Amazon.com.