Circular ceramic devices make more efficient transformers

November 30, 1999

Boston, Mass. -- Thinner laptop computers and flat-screen TVs may be possible with a simple change in the geometry of piezoelectric transformers that can increase the conversion ratio without adding volume or weight, according to Penn State researchers.

"Conventional electromechanical transformers are big, very heavy and produce a great deal of magnetic noise that, without shielding, can wipe floppy disks, tapes and hard drives," says Dr. Kenji Uchino, professor of electrical engineering and member of Penn State's Materials Research Laboratory. "Rectangular piezoelectric ceramic transformers have been commercially in use since 1994 especially for computer notebook applications. Our circular configuration, made with improved materials, advances this field and opens the way for more powerful, light-weight transformers."

Electromagnetic transformers consist of two coils of wire that convert high voltages to lower ones or low voltages to higher ones. The size of the step-up or step-down depends on the difference between the number of turns of wire in each coil. Large electromagnetic transformers are very efficient, but miniaturization decreases the efficiency.

Uchino, Burhanettin Koc, postdoctoral associate in electrical engineering, and Yongkang Gao, graduate student in materials science and engineering, worked on disk-shaped transformers made of an enhanced piezoelectric material consisting of a lead, zirconium, titanium ceramic doped with manganese and cerium. The researchers reported their research today (Dec. 1) at the annual meeting of the Materials Research Society in Boston.

"The screen uses most of the energy consumed by a notebook computer," says Uchino. "The liquid crystal display uses fluorescent lights to backlight the screen and these lights take high voltage to turn on."

Most portable computers run on 12-volt batteries, but it takes 500 volts to turn on the screen backlight, while it takes only 250 to 300 volts to continue their operation. Uchino collaborated with NEC Corporation in Japan in developing the rectangular piezoelectric transformers currently in use in their notebooks, but the circular wafers promise increased efficiency and higher conversion ratios.

In the circular wafer, about one-third of the wafer is used for a crescent shaped input electrode with the remaining two-thirds as output. The disk transformer provides a voltage step up ratio of about 60 rather than the rectangular rate of just over 40 because it uses more than one vibration mode. The circular wafers take up the same volume and weigh the same as rectangular transformers.

Piezoelectric material moves when under an electric current, and, when displaced by outside pressure, these materials produce an electric current.

Transformers are made from piezoelectric materials by applying a chopped electric charge to one side of a piezoelectric wafer. This on and off charge creates a vibration in the material, which is converted to an ac current on the other side of the wafer. Piezoelectric ceramics are manufactured using conventional sintering methods, and electrodes can be screened onto the wafers.

"Piezoelectric transformers are not only more efficient, smaller and lighter, but they are also much less expensive to manufacture than conventional coil wound transformers," says Uchino.

He warns, however, that piezoelectric transformers are not necessarily the answer to all power problems. For one thing, in any transformer, as the voltage is increased, the current decreases, so transformers are only applicable where current is unimportant. Also, piezoelectric transformers have only been tried in a few applications, and there may be unforeseen problems with their use. The researchers are, however, looking into developing piezoelectric transformers for use on the battlefield to replace the enormous transformers needed to operate x-ray equipment. These machines can require as much as 10 kilovolts, but not much current. In these applications, 20 or more disk transformers might be stacked and still take up only a fraction of the weight and volume of a conventional transformer. In the other direction, the researchers are looking at step-down applications for audio amplification.
-end-
EDITORS: Dr. Uchino is at 814-863-8035 orkxu1@alpha.mrl.psu.edu by email.
Dr.Koc may be reached at 814-863-2927 or
bxk142@psu.eduby email.

Penn State

Related Weight Articles from Brightsurf:

How much postmenopause weight gain can be blamed on weight-promoting medications?
Abdominal weight gain, which is common during the postmenopause period, is associated with an array of health problems, including diabetes and heart disease.

Commercial weight management groups could support women to manage their weight after giving birth
Women who were overweight at the start of their pregnancy would welcome support after they have given birth in the form of commercial weight management groups, University of Warwick-led research has found.

Rollercoaster weight changes can repeat with second pregnancy, especially among normal-weight women
Everyone knows that gaining excess weight during one pregnancy is bad, but clinicians rarely consider weight gains and losses from one pregnancy to the next -- especially in normal-weight women.

Early and ongoing experiences of weight stigma linked to self-directed weight shaming
In a new study published today in Obesity Science and Practice, researchers at Penn Medicine and the University of Connecticut Rudd Center for Food Policy and Obesity surveyed more than 18,000 adults enrolled in the commercial weight management program WW International, and found that participants who internalized weight bias the most tended to be younger, female, have a higher body mass index (BMI), and have an earlier onset of their weight struggle

Being teased about weight linked to more weight gain among children, NIH study suggests
Youth who said they were teased or ridiculed about their weight increased their body mass by 33 percent more each year, compared to a similar group who had not been teased, according to researchers at the National Institutes of Health.

Association between weight before pregnancy, weight gain during pregnancy and adverse outcomes for mother, infant
An analysis that combined the results of 25 studies including nearly 197,000 women suggests prepregnancy body mass index (BMI) of the mother was more strongly associated with risk of adverse maternal and infant outcomes than the amount of gestational weight gain.

Study: Faster weight loss no better than slow weight loss for health benefits
Losing weight slowly or quickly won't tip the scale in your favor when it comes to overall health, according to new research.

What your choice of clothing says about your weight
It's commonly said that you can tell a great deal about a person by the clothes they wear.

Stand up -- it could help you lose weight
You might want to read this on your feet. A new study published today in the European Journal of Preventive Cardiology found that standing instead of sitting for six hours a day could prevent weight gain and help people to actually lose weight.

Cash for weight loss
A new study, published in the journal Social Science and Medicine, has shown that selling rewards programmes to participants entering a weight loss programme is a low cost strategy to increase both the magnitude and duration of weight loss.

Read More: Weight News and Weight Current Events
Brightsurf.com is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to Amazon.com.