Exposing the roots of the lithium battery problem

December 17, 2013

The lithium-ion batteries that power our laptops, smartphones and electric vehicles could have significantly higher energy density if their graphite anodes were to be replaced by lithium metal anodes. Hampering this change, however, has been the so-called dendrite problem. Over the course of several battery charge/discharge cycles, particularly when the battery is cycled at a fast rate, microscopic fibers of lithium, called "dendrites," sprout from the surface of the lithium electrode and spread like kudzu across the electrolyte until they reach the other electrode. An electrical current passing through these dendrites can short-circuit the battery, causing it to rapidly overheat and in some instances catch fire. Efforts to solve the problem by curtailing dendrite growth have met with limited success, perhaps because they've just been scratching the surface of the problem.

Researchers with the U.S. Department of Energy (DOE)'s Lawrence Berkeley National Laboratory (Berkeley Lab) have discovered that during the early stages of development, the bulk of dendrite material lies below the surface of the lithium electrode, underneath the electrode/electrolyte interface. Using X-ray microtomography at Berkeley Lab's Advanced Light Source (ALS), a team led by Nitash Balsara, a faculty scientist with Berkeley Lab's Materials Sciences Division, observed the seeds of dendrites forming in lithium anodes and growing out into a polymer electrolyte during cycling. It was not until the advanced stages of development that the bulk of dendrite material was in the electrolyte. Balsara and his colleagues suspect that non-conductive contaminants in the lithium anode trigger dendrite nucleation.

"Contrary to conventional wisdom, it seems that preventing dendrite formation in polymer electrolytes depends on inhibiting the formation of subsurface dendritic structures in the lithium electrode," Balsara says. "In showing that dendrites are not simple protrusions emanating from the lithium electrode surface and that subsurface non-conductive contaminants might be the source of dendritic structures, our results provide a clear prescription for the path forward to enabling the widespread use of lithium anodes."

Balsara, who is a professor of chemical engineering at the University of California (UC) Berkeley, is the corresponding author of a paper describing this research in Nature Materials titled "Detection of subsurface structures underneath dendrites formed on cycled lithium metal electrodes." Co-authors are Katherine Harry, Daniel Hallinan, Dilworth Parkinson and, Alastair MacDowell.

The tremendous capacity of lithium and the metal's remarkable ability to move lithium ions and electrodes in and out of an electrode as it cycles through charge/discharge make it an ideal anode material. Until now, researchers have studied the dendrite problem using various forms of electron microscopy. This is the first study to employ microtomography using monochromatic beams of high energy or "hard" X-rays, ranging from 22 to 25 keV, at ALS beamline 8.3.2. This technique allows non-destructive three-dimensional imaging of solid objects at a resolution of approximately one micron.

"We observed crystalline contaminants in the lithium anode that appeared at the base of every dendrite as a bright speck," says Katherine Harry, a member of Balsara's research group and the lead author of the Nature Materials paper. "The lithium foils we used in this study contained a number of elements other than lithium with the most abundant being nitrogen. We can't say definitively that these contaminants are responsible for dendrite nucleation but we plan to address this issue by conducting in situ X-ray microtomography."

Balsara and his group also plan further study of the role played by the electrolyte in dendrite growth, and they have begun to investigate ways to eliminate non-conductive impurities from lithium anodes.
This research was funded by the DOE Office of Science.

Lawrence Berkeley National Laboratory addresses the world's most urgent scientific challenges by advancing sustainable energy, protecting human health, creating new materials, and revealing the origin and fate of the universe. Founded in 1931, Berkeley Lab's scientific expertise has been recognized with 13 Nobel prizes. The University of California manages Berkeley Lab for the U.S. Department of Energy's Office of Science. For more, visit http://www.lbl.gov.

DOE's Office of Science is the single largest supporter of basic research in the physical sciences in the United States, and is working to address some of the most pressing challenges of our time. For more information, please visit the Office of Science website at science.energy.gov/.

DOE/Lawrence Berkeley National Laboratory

Related Dendrites Articles from Brightsurf:

Reelin-Nrp1 interaction regulates neocortical dendrite development
Reelin exhibits a context-dependent function during brain development; however, its underlying mechanism is not well understood.

No more playing with fire: Study offers insight into 'safer' rechargeable batteries
Lithium-ion batteries are used in various electronic devices. But, they also come with potential hazards, particularly if the battery is damaged or overcharged.

New lithium battery charges faster, reduces risk of device explosions
Cell phone batteries often heat up and, at times, can burst into flames.

Protecting the neuronal architecture
Protecting nerve cells from losing their characteristic extensions, the dendrites, can reduce brain damage after a stroke.

'Spillway' for electrons could keep lithium metal batteries from catching fire
UC San Diego nanoengineers developed a safety feature that prevents lithium metal batteries from rapidly overheating and catching fire in case of an internal short circuit.

Potassium metal battery emerges as a rival to lithium-ion technology
In research published in Proceedings of the National Academy of Sciences, researchers from Rensselaer Polytechnic Institute demonstrate how they can overcome a persistent challenge known as dendrites to create a metal battery that performs nearly as well as a lithium-ion battery, but relies on potassium -- a much more abundant and less expensive element.

Researchers show advance in next-generation lithium metal batteries
A Washington State University research team has developed a way to address a major safety issue with lithium metal batteries - an innovation that could make high-energy batteries more viable for next-generation energy storage.

A new method to study lithium dendrites could lead to better, safer batteries
Lithium ion batteries often grow needle-like structures between electrodes that can short out the batteries and sometimes cause fires.

Newly identified dendritic action potentials give humans unique brain power
Newly discovered action potentials in neuronal dendrites neurons uniquely amplify the computational power of the human brain, according to a new study.

Dendrites filtering neuron's excitement
Kyoto University research shows that Purkinje cell dendrites filter out signals to the Soma.

Read More: Dendrites News and Dendrites Current Events
Brightsurf.com is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to Amazon.com.